TROUBLESHOOTING
CHECK
9. Ch}ck oil level. Also check
oil for contamination
CRAl\!KCASE IS FILLED TO
PROPER LEVEL
10. ChJck if engine overheats
ENGINE IS NOT OVERHEATED
j
11. Accelerate or run at high speed
ENGINE DOES NOT KNOCK
POOR PERFORMANCE AT LOW AND IDLE SPEEDS
CHECK
Check ignition timing
1.
NORMAL
Ch}ck carburetor air screw
adjustment
2 .
NORMAL
leaking past carburetor
3.
packing
Air is
NOT LEAKING
j
4.
Remove spark plug and try
spark test
GOOD SPARKS
18-4
LEVEL IS TOO LOW OR T00-----(1) Transmissio oil level too high,
HIGH
ENGINE OVERHEATS-------(1) Improperly adjusted oil pump
ENGINE KNOCKS---------(1) Worn piston rings and cylinder
INCORRECT
INCORRECT
LEAKING
WEAK OR INTERMIITENT
SPARK
�HONDA
� MBX50· MBX80
PROBABLE CAUSE
resulting in lack of power
(2) Transmission oil level too low
(3) No engine oil in oil tank
(4) Oil deteriorated or contami
nated
(2) Excessive carbon build-up in
combustion chamber
(3) Use of improper quality fuel
(4) Mixture too lean
(5) Clutch slipping
(2) Fuel air mixture too lean
(3) Excessive carbon build-up in
combustion chamber
(4) Ignition timing too early
(advanced)
PROBABLE CAUSE
( 1) Faulty COi unit
Faulty alternator
(2)
( 1) Fuel air mixture too lean
(To correct, screw in)
Fuel air mixture too rich
(To correct, screw out)
(2)
( 1) Deteriorated insulator
0-ring
Loose carburetor
Deteriorated carburetor
(2)
(3)
packing
( 1)
Defective, or carbon or wet
fouled spark plug
Faulty alternator
Faulty ignition coil
(2)
(4) Faulty COi unit
(3)