Left Crankcase Cover Removal; Left Crankcase Cover Installation - Honda CRF110F Service Manual

AL TERNATORISTARTER CLUTCH
LEFT CRANKCASE COVER
REMOVAL
Be
C8ffJful not to
damsge the mating
surface.
The /eft
crankcase
cover is
magflfltica/fy
attracted
to
the
flywheel, b8 careful
during installation.
11-4
Remove the left crankcase rear cover (page 2-7).
Drain the engine oil (page 3-10).
Disconnect the following:
- Alternator 2P connector (1]
- Ignilion pulse generator wire connector [2)
Loosen the bolls [3] in a crisscross pattern in several
steps, then remove the bolls and hose guide [4].
Remove the left crankcase cover [5].
Remove the dowel pins (1) and gasket [2).
INSTALLATION
Clean any gasket material from the left crankcase cover
and crankcase mating surface.
Install the dowel pins [1] and a new gasket (2].
Apply engine oil to the reduction gear journal of the left
crankcase cover.
InsleUthe left crankcase cover [1J.
Install the hose guide (2) and bolts [3), then tighten
them In a crisscross pattern in several steps.
Connect the following:
- Alternator
2P
connector
[4]
- Ignition pulse generator wire connector
(51
Fill the engine with the recommended engine oil
(page 3- 10).
Inslalilhe left crankcase rear cover (page 2-7).