Yamaha 2006 RX10GTAXW Service Manual page 17

GENERAL MAINTENANCE AND LUBRICATION CHART
Item
Primary and secondary
clutches
Steering column bearing
Ski and front suspension
Suspension component
Parking brake cable end and
lever end/throttle cable end
Shroud latches
Fitting and fasteners
Tool kit and recommended
equipment
NOTE:
Brake system:
1. After disassembling the master cylinder or caliper cylinder, always change the brake fluid. Regu-
larly check the brake fluid level and add fluid if necessary.
2. Replace the oil seals of the master cylinder and caliper cylinder every two years.
3. Replace the brake hose every four years, or if cracked or damaged.
Remarks
Check engagement and shift speed.
Adjust if necessary.
Inspect sheaves for wear/damage.
Inspect weights/rollers and bushings for wear-for pri-
mary.
Inspect ramp shoes/bushings for wear-for secondary.
Replace if necessary.
Lubricate with specified grease.
Lubricate with specified grease.
Lubricate with specified grease.
Lubricate with specified grease.
Lubricate with specified grease.
Check cable damage.
Replace if necessary.
Make sure that the shroud latches are hooked.
Check tightness.
Repair if necessary.
Check for proper placement.
Pre-opera-
tion check
(Daily)
Whenever operating elevation is
4
INSP
ADJ
Every
Initial
1 month or
Seasonally
800 km
or 4,000 km
(500 mi)
(2,500 mi)
(40 hr)
(200 hr)
changed.