Fuel Hose; Clutch - HYOSUNG 2010 ST7 Service Manual

FUEL HOSE

Inspect Interval
Inspect Initial 1,000 km and Every 6,000 km thereafter.
Replace every 4 years.
Remove the seat. (Refer to page 8-1)
Remove the fuel tank. (Refer to page 5-2)
Remove the frame cover. (Refer to page 8-2)
Inspect the fuel hoses for damage and fuel leakage.
If any defects are found, the fuel hoses must be
replaced.

CLUTCH

Inspect Interval
Inspect Initial 1,000 km and Every 6,000 km thereafter.
Clutch play should be 2 mm (0.08 in) as measured at the
clutch lever holder before the clutch begins to disengage.
If the play in the clutch is incorrect, adjust it in the following
way :
A basis adjustment be allowed by the clutch lever
adjuster ②.
Uncover the rubber boot ⑤.
Loosen the lock nut ① counter-clockwise.
Turn the clutch lever adjuster ② in or out to acquire
the specified play.
After end of adjustment, tighten the lock nut ① clock-
wise fully and cover the rubber boot ⑤
If not adjust by the clutch lever adjuster ② adjust by
the clutch cable adjuster ④.
Loosen the clutch cable adjuster lock nut ③.
Turn the clutch cable adjuster ④ in or out to acquire
the specified play.
After end of adjustment, tighten the lock nut ③
The clutch cable should be lubricated with a light
weight oil whenever it is adjusted.
Clutch cable play
▣ ▣ GEARSHIFT LEVER HEIGHT
ADJUSTMENT
Loosen the lock nut ⑥
With the link rod ⑦ turned, adjust the gearshift lever
height.
Tighten the lock nut ⑥.
2 mm (0.08 in)
PERIODIC MAINTENANCE 2-10
⑤
②
③
⑥
⑦
①
④
⑥