Club Car Precedent 2016 Maintenance And Service Manual page 437

test procedures, index of
pedal-start gasoline vehicle............................... 18-14
test procedures, motor
1 internal short circuits........................................ 16-2
2 armature circuit open ....................................... 16-2
3 field circuit open .............................................. 16-3
armature ground test .......................................... 16-9
test procedures, pedal-start gasoline vehicle
18-pin connector .............................................. 18-21
4-pin connector ................................................ 18-41
accelerator pedal limit switch function ................ 18-25
battery ............................................................. 18-16
battery load test ............................................... 18-36
ECU ................................................................ 18-21
EFI .................................................................. 18-21
engine kill limit switch function........................... 18-26
engine temperature sensor ............................... 18-21
fuel gauge........................................................ 18-39
fuel injector ...................................................... 18-21
fuel level sending unit ....................................... 18-38
fuel pump......................................................... 18-37
fuses ............................................................... 18-19
ground cables .................................................. 18-20
ignition coil....................................................... 18-34
iignition spark................................................... 18-33
key switch
starter circuit (pedal-start) .............................. 18-24
key switch (engine kill circuit) ............................ 18-24
low oil warning light .......................................... 18-35
maintenance/operate switch.............................. 18-28
MAP sensor ..................................................... 18-21
neutral lockout limit switch ................................ 18-29
oil level sensor ................................................. 18-36
reverse buzzer ................................................. 18-35
reverse buzzer limit switch ................................ 18-35
solenoid........................................................... 18-27
starter/generator............................................... 18-30
voltage regulator .............................................. 18-32
testing
armature ground test (starter/generator) .............. 19-8
spark plug.......................................................... 20-6
throttle body ..................................................21-1, 21-3
installation ......................................................... 21-5
removal ............................................................. 21-3
throttle position sensor ...................................... 5-3, 5-5
tie rod and drag link
installation ........................................................... 7-8
removal ............................................................... 7-6
tire
installation ........................................................... 8-3
removal ............................................................... 8-2
repair................................................................... 8-2
tools
see service tools ................................................ 24-3
torque converter
troubleshooting .................................................. 23-1
Tow/Run switch ..................................................... 12-3
installation ......................................................... 13-6
removal ............................................................. 13-6
testing ............................................................. 12-20
transaxle
installation ....................................................... 24-12
lubrication .......................................................... 24-2
removal ............................................................. 24-9
service............................................................... 24-2
transaxle, type g
assembly ........................................................... 17-9
axle bearing ....................................................... 17-4
axle shaft
installation ...................................................... 17-4
removal .......................................................... 17-1
disassembly....................................................... 17-7
inspection .......................................................... 17-7
installation ....................................................... 17-10
lubrication .......................................................... 17-1
oil seal
installation ...................................................... 17-4
removal .......................................................... 17-1
removal ............................................................. 17-5
troubleshooting...................................................... 12-4
CDT handheld programmer................................11-26
torque converter ................................................. 23-1
troubleshooting guide 1......................................12-11
troubleshooting guide 2..................................... 12-14
troubleshooting guide
gasoline vehicle ................................................. 18-2
U
universal accessory mounting................................. 4-11
V
Visage
connector, 4-pin
see test procedures............................. 12-37, 18-41
voltage regulator
installation ....................................................... 19-17
removal ........................................................... 19-17
testing ............................................................. 18-32
W
walk away braking ................................................. 12-3
water level
see batteries, electrolyte level ........................... 14-10
wheel
installation ........................................................... 8-1
removal ............................................................... 8-1
see also tire ......................................................... 8-1
wheel bearing
installation ......................................................... 24-7
removal ............................................................. 24-7
wheel, steering
installation ........................................................... 7-2
removal ............................................................... 7-1
2016 Precedent Golf Car Maintenance and Service Manual
INDEX
Index-7