Periodic Service Schedules - Club Car Precedent 2016 Maintenance And Service Manual

10

Periodic Service Schedules

WARNING
• Frame ground – Do not allow tools or other metal objects to contact frame when disconnecting
batteries or other electrical wiring. Never allow a positive wire to touch the vehicle frame, engine,
or other metal component.
PERIODIC SERVICE SCHEDULES
WARNING
• Service, repairs, and adjustments must be made per instructions in the maintenance and service
manual.
• If any problems are found during scheduled inspection or service, do not operate the vehicle until
repairs are made. Failure to make necessary repairs could result in fire, property damage, severe
personal injury, or death.
NOTE: If the vehicle is constantly subjected to heavy use or severe operating conditions, the preventive maintenance
procedure should be performed more often than recommended in the periodic service and lubrication
schedules.
Both the Periodic Service Schedule and Periodic Lubrication Schedule must be followed to keep vehicle in
optimum operating condition.
_
PERIODIC SERVICE SCHEDULE – ELECTRIC VEHICLES
REGULAR INTERVAL
Daily service by owner
Weekly service by owner
Monthly service by owner or trained
technician
TABLE CONTINUED ON NEXT PAGE
Page 10-4 2016 Precedent Golf Car Maintenance and Service Manual
SERVICE
Pre-Operation and Daily Safety Checklist
Performance Inspection
Batteries
Batteries (For vehicles NOT equipped with the
Single-Point Watering System and Side-Post
Batteries)
Batteries (For vehicles equipped with the
Single-Point Watering System). Water monthly
or according to the established watering
interval.
Batteries
Tires
General vehicles
PERIODIC MAINTENANCE
See Pre-Operation and Daily Safety
Checklist on page 10-1.
See Performance Inspection on page 10-2.
Charge batteries (after each daily use only).
Check electrolyte level. Add water if
necessary.
Water the batteries. Observe that water flow
occurs and no water overflows from any cell.
Wash battery tops and clean terminals with
baking soda/water solution. Apply Battery
Terminal Protector Spray (CC P/N 1014305) to
battery terminals.
Check air pressure and adjust if necessary.
See Vehicle Specifications – Electric and
Subaru EX40 on page 2-1.
Thoroughly wash vehicle including the
underside.