Club Car Precedent 2016 Maintenance And Service Manual page 148

11
Connection Tests
1. Using a multimeter set for 200 ohms, place the red (+) probe into one of the terminals on the end of the cord with
the square plug.
2. Place the black (–) probe on each of the pins, one at a time, on the plug on the other end of the cord.
3. The multimeter should indicate continuity on only one pin. If any other reading is obtained, the cord must be
replaced.
4. Repeat the procedure three more times, each time with the red (+) probe inserted into a different terminal on
the end of the cord with the square plug.
TEST PROCEDURE 2 – Handset Cord Adaptor
See General Warnings on page 1-2.
The procedure for testing the handset cord adaptor is similar to the cord test.
1. Using a multimeter set for 200 ohms, place the red (+) probe into one of the terminals on the end of the adapter
with the square plug.
2. Place the black (–) probe on each of the pins, one at a time, on the other plug of the adaptor.
3. The multimeter should indicate continuity on only one pin. If any other reading is obtained, the adaptor must
be replaced.
4. Repeat the procedure three more times, each time with the red (+) probe inserted into a different terminal on the
end of the adaptor with the square plug.
TEST PROCEDURE 3 – CDT Ports
Inspect the CDT ports for damage or corrosion.
CDT PORT (LOCATED UNDER INSTRUMENT PANEL)
See General Warnings on page 1-2.
1. Turn the key switch to the OFF position, place the Forward/Reverse rocker switch in the NEUTRAL position,
and lock the park brake.
2. Place the Tow/Run switch in the TOW position, disconnect the batteries, negative (–) cable first, and wait 90
seconds for the controller capacitors to discharge. See General Warnings on page 1-2.
3. Check the CDT port mounted under the instrument panel.
3.1. Remove the three screws (1) that secure the instrument panel assembly (2) to the dash assembly (3)
(Figure 11-3, Page 11-29).
Page 11-28 2016 Precedent Golf Car Maintenance and Service Manual
CONTROLLER DIAGNOSTIC TOOL (CDT)