Table of Contents
Advertisement
Hazards and Actions
The following actions are recommended regarding these hazards:
• Do not go near a fuel spill or allow anyone else in the area.
• Use station EMERGENCY CUTOFF immediately. Turn off all system circuit breakers to the island(s).
• Do not use console E-STOP, ALL STOP, and PUMP STOP to shut off power. These keys do not remove
AC power and do not always stop product flow.
• Take precautions to avoid igniting fuel. Do not allow starting of vehicles in the area. Do not allow open
flames, smoking or power tools in the area.
• Do not expose yourself to hazardous conditions such as fire, spilled fuel or exposed wiring.
• Call emergency numbers.
Encore CNG Automatic Safety Systems
Unique automatic disconnect functions are included in the Encore CNG dispenser which contains a
hydrocarbon sensor and impact detector/tilt switch. These devices switch power off inside the dispenser
automatically in a hazardous fault condition and send a signal that can be utilized to switch off the site
automatically. However, the above recommended actions (regarding collision of vehicle on island or site or
gas leak) are still applicable and these automatic devices should not be relied upon to ensure the site is
made safe and the manual intervention described above must be enacted.
CNG dispenser in collision with vehicles damaged with fire or explosions must be removed from
service and replaced.
Breakaways must be installed to provide safety protection in the event of a drive-off while the
nozzle is connected. CNG dispenser MUST NOT be used in service without approved
breakaways being installed.
Adapters are not to be used at the vehicle fuel connection.
MDE-5411A ForeHB Islander Prime Installation Manual · October 2018
WARNING
Spilled fuels, accidents involving pumps/dispensers, or uncontrolled fuel flow create a
serious hazard.
Fire or explosion may result, causing serious injury or death.
Follow established emergency procedures.
Collision of a Vehicle with Unit
WARNING
WARNING
Important Safety Information
Fire at Island or Site
Gas Leak
Page 7
Advertisement
Table of Contents
