Maintenance; Fluid Recommendation; Preventative Maintenance; Manual Override - Tiffin Motorhomes VANLEIGH BEACON Owner's Manual

10 6 10 6
NOTE: If the Auto Level sequence does not perform as described above, test that the jacks operate
correctly by pushing their coordinating buttons on the Linc remote; e.g., "FRONT" button operates
M A I N T E N A N c E
only the front jacks, etc. The jacks can also be tested in manual mode on the OneControl Touch
Panel (Fig. 2). See Operation - MyRV OneControl Touch Panel.

Maintenance

FLUID REcoMMENDATIoN

Fluid Recommendation

PREVENTATIVE MAINTENANcE

Automatic transmission fluid (ATF) with Dexron
Lippert Components, Inc. For a list of approved fluid specifications, see TI-188. To obtain this Technical
Information sheet on-line, go to http://www.lci1.com/support-lci4a3lcd. Then click on the Technical
M A N U A L o V E R R I D E
Information Sheets tab. Look for TI-188: Hydraulic Operation Fluid Recommendation within the listing.
NOTE: In colder temperatures (less than 10 ° F) the jacks may extend and retract slowly due to the fluid's
molecular nature. For cold weather operation, fluid specially formulated for low temperatures may
be desirable.
Preventative Maintenance
1. Check hydraulic fluid in reservoir every 12 months. If fluid is a clear, red color, do not change. If fluid is
milky, pink and murky, and not clear red in color, drain reservoir and add new fluid. Hydraulic fluid in
reservoir should be changed a minimum of every five years.
NOTE: Check the fluid only when all the jacks are fully retracted.
NOTE: When checking the hydraulic fluid level, fill to within
2.
Inspect and clean all power unit electrical connections every 12 months. If corrosion is evident, use a
small amount of lubricant to remove corrosion. Contacts must be cleaned with a non-residue cleaner
prior to use. LCI recommends the use of an electrical contact cleaner spray.
3. Remove dirt and road debris from jacks as needed.
The coach should be supported at both front and rear axles with jack stands before working
underneath. Failure to do so may result in death, serious personal injury or severe product or
4. If jacks are down for extended periods, it is recommended to spray exposed jack rods with a dry
silicone lubricant every three months for protection. If the trailer is located in a salty environment, it is
recommended to spray the rods every four to six weeks.

Manual Override

The LCI Level-Up Automatic Leveling System can be manually operated with an electric drill. In the event of
electrical or system failure, this manual method of extending and retracting the jacks can be used. See the
instructions below.
NOTE: Unhook the power unit motor from the power source prior to attempting the manual override
procedure.
1 0 6 1 0 6
Rev: 03.25.19
III or Mercon V or a blend of both is recommended by
® ®
1/4 1/2
" to
property damage.
VA N L E I G H B E A c o N VA N L E I G H B E A c o N
Page 16
" of fill spout.
Re
CCD-0001539