Eaton 93pm Installation Manual page 31

C C h h a a p p t t e e r r 4 4 I I n n s s t t a a l l l l a a t t i i o o n n
4 4 . . 1 1 P P r r e e l l i i m m i i n n a a r r y y I I n n s s t t a a l l l l a a t t i i o o n n I I n n f f o o r r m m a a t t i i o o n n
Installation should be performed only by qualified personnel knowledgeable of batteries and the required
precautions.
Observe these precautions while installing the Integrated Battery Cabinet (IBC):
• Remove watches, rings, or other metal objects.
• Use tools with insulated handles.
• Wear voltage rated gloves and electrical hazard footwear.
• Do not lay tools or metal parts on top of batteries or battery cabinets.
• Refer to Chapter 3 Installation Plan and Unpacking for cabinet dimensions and weight, wiring and
terminal data, and installation notes.
• Do not tilt the cabinets more than 10° during installation.
Failure to follow these instructions may result in severe injury or death.
4 4 . . 2 2 U U n n l l o o a a d d i i n n g g t t h h e e I I B B C C C C a a b b i i n n e e t t f f r r o o m m t t h h e e P P a a l l l l e e t t
RISK OF INSTABILITY. Do not remove any internal panels until the cabinet is removed from and lowered from
the pallet.
The IBC is heavy (see
may tip and cause serious injury or death.
• Do not tilt cabinet more than 10° from vertical.
• Lift the cabinets only with a forklift or pallet jack or damage may occur.
The IBC is bolted to a pallet consisting of four metal angle supports secured to two wood supports.
To remove the pallet:
Do not use the jacking bolts on a soft surface floor. Use only on a hard surface, such as concrete. If necessary
remove pallet on a hard surface and roll cabinet to final installation position.
Table 1). If unpacking and unloading instructions are not closely followed, the cabinet
NOTE For the following procedures, verify that the forklift or pallet jack is rated to handle the
weight of the cabinet (see
Eaton 93PM Integrated Battery Cabinet-Small (IBC-S) Installation Manual 164000305—Rev 06
WARNING
DANGER
WARNING
CAUTION
Table 1 for cabinet weight).
CAUTION
23