Starter Motor - Arctic Cat DVX 400 2008 Service Manual

FOR ARCTIC CAT ATV DISCOUNT PARTS CALL 606-678-9623 OR 606-561-4983
NOTE: If voltage is lower than specified, test
Charging Coil - No Load.
VOLTAGE (Charging Coil - No Load)
NOTE: The peak voltage reading adapter must be
disconnected for this test.
The connector is the black one on the left side near the
voltage regulator.
NOTE: Test the connector that comes from the
engine.
1. Set the meter selector to the AC Voltage position.
2. Test between the three brown wires for a total of
three tests.
3. With the engine running at a constant 5000 RPM,
all wire tests must show 65+ AC volts.
! CAUTION
Do not run the engine at high RPM for more than 10
seconds.
NOTE: If both charging coil tests failed, check all
connections, etc., and test again. If no voltage is
present, replace the stator assembly.
www.mymowerparts.com
Back
5-8
SP084A
AR630D
Back to TOC
RESISTANCE (Charging Coil)
! CAUTION
Always disconnect the battery when performing
resistance tests to avoid damaging the multimeter.
1. Set the meter selector to OHMS position.
2. Test between the three brown wires for a total of
three tests.
3. The meter reading must be within specification.
RESISTANCE (Trigger Coil)
! CAUTION
Always disconnect the battery when performing
resistance tests to avoid damaging the multimeter.
1. Set the meter selector to the OHMS position.
2. Connect the red tester lead to the green wire; then
connect the black tester lead to the blue wire. The
meter reading must be within specification.
PEAK VOLTAGE (Magneto Coil -
Trigger)
1. Set the meter selector to the DC Voltage position.
2. Connect the red tester lead to the green wire; then
connect the black tester lead to the blue wire.
3. Crank the engine over using the electric starter.
4. The meter reading must be within specification.

Starter Motor

KEY
1. Starter Motor
2. Brush Terminal Set
3. O-Ring
4. Brush Holder Set
5. Brush Spring
6. O-Ring
7. Washer Set
8. Through-Bolt
9. O-Ring
10. O-Ring
11. Bolt
12. Nut
Back to Section TOC
0739-228
Next