Advertisement
Pump / Drive Assembly Instructions
Install Front Tank Mounts &
Front frame Rail Supports:
.
1
Remove Bolts from Tractor Frame
Rails. Find the front most 4 Bolts in the Tractor
Frame Rail, There are 4 on the RH side and 4 on
the LH Side. DO NOT REMOVE THE BOLTS
FROM BOTH SIDES AT THE SAME TIME,
ONLY do one side at a time the RH or the LH.
For illustration start with the RH Side (See
Figure 11). The RH & LH Frame Rail Supports
have a Right and a Left. They will not inter-
change and must be mounted on the correct
side. Notice the way they are built, the Plate part
that bolts to Tractor is longer in the front on both
LH & RH. Make sure the longest part is to the
front (See Figure 13).
2.
Install Frame Rail Support and Tank
Mount Frame RH Side. This works best with a
2 man team. The RH Tank Mount Bracket and
the Front Frame Rail Support is held on with the
same Bolts. Install with the Tank Bracket next to
Tractor then the Frame Rail Support Bracket.
Start all 4 bolts with Lockwasher before any of
the 4 are tightened (See Figure 12). When
tightened down it will look like the picture in
Figure 13.
3.
Install Frame Rail Support and Tank
Mount Frame LH Side. This will install the same
as the RH side did. Remove the 4 bolts; Install
the Tank Bracket next to tractor then the Front
Frame Rail Support. Tighten the 4 bolts through
Tractor Frame Rail.
Check to make sure the Tank Brackets
are mounted correctly, The tank Brackets have
Bends in them that bend to the Outside (See
Figure 12). This makes the Tank Brackets
wider where the tank slides in than where they
are bolted to the tractor.
There is also a front Bumper Plate that
bolts between the Tank Bracket with 3 bolts on
each side. DO NOT install Bumper or Tank at
this time, they cannot be installed untill after the
Pump is installed.
Machete (JD -62,63,6420 Asy Man) 10/04
© 2004 Alamo Group Inc.
Splined Clamp Yoke
/ Tube End
Figure 9
Shaft 1/2 Assembly
w/ Flanged Yoke
Tractor
Radiator
Figure 10
Figure 11
Section 3 - 6
Flange Yoke
/ Shaft End
Drive Shaft
Assembly
Tractor Engine
Left Hand front side
of Tractor
Tractor Frame Rail
Bolts(4)
Advertisement
