SECTION 13—MAINTENANCE AND TROUBLESHOOTING
Lubrication Points
NOTE: For this procedure, refer to FIGURE 13.1.
1. Every six (6) months, lubricate the top of the seat post using a Teflon lubricant.
Seat Post
(TOP)
Electrical
SYMPTOM
Batteries draw excessive current
when charging.
Battery indicator flashes the
charge level is low - immediately
after recharge.
Battery indicator flashes the
charge level is low - too soon
after being recharged.
Motor "chatters" or runs irregu-
lar.
Powered scooter does not
respond to commands.
Power indicator off - even after
recharging.
Zoom 300 and Zoom 400
FIGURE 13.1 Lubrication Points
PROBABLE CAUSE
Battery failure.
Electrical malfunction.
Battery failure.
Malfunctioning battery
charger.
Electrical malfunction
Batteries not charged.
Weak batteries
Electrical malfunction.
Poor battery terminal con-
nection.
Electrical malfunction.
100
Seat
SOLUTIONS
Check batteries. Replace if necessary.
Contact Invacare for service.
Check batteries. Replace if necessary.
Contact Invacare for Service.
Contact Invacare for Service.
Check charger. Replace if necessary.
Replace batteries if necessary. Contact Invac-
are for Service.
Contact Invacare for Service.
Clean terminals.
Contact Invacare for Service.
Part No 1122167