Changing The Fuel Pump - Husqvarna FE 350 2014 Repair Manual

12
FUEL TANK, SEAT, TRIM
m 12.11
Changing the fuel
Danger
Fuel is highly flammable.
Fire hazard
-
Never refuel the vehicle near open flames or burning cigarettes, and always switch off the engine first. Be careful that no
fuel is spilt, especially on hot vehicle components. Clean up spilt fuel immediately.
-
The fuel in the fuel tank expands when warm and may emerge if overfilled. Follow the instructions on refueling.
A
Warning
Danger of poisoning
-
Fuel must not come into contact with the skin, eyes, or clothing. Do not breathe in the fuel vapors. If contact occurs with
the eyes, rinse with water immediately and contact a physician. Immediately clean contaminated areas on the skin with
soap and water. If fuel is swallowed, contact a physician immediately. Change clothing that has been contaminated with
fuel. Store fuel properly in a suitable canister and keep away from children.
Warning
Environmental hazard
-
Do not allow fuel to get into the ground water, the ground, or the sewage system.
-
Mount fuel filter
✓ Arrow
-
Mount hose clamps
I
Hose clamp pliers (600290 5 7000) (or p. 261)
305316-10
-
Position the fuel pump.
-
Mount fuel connection @ with the gasket but do not tighten yet.
Guideline
I
Fuel connection on fuel pump
-
Mount and tighten nut
Guideline
I
Nut, fuel pump fixation
-
Tighten fuel connection@.
305313-10
Guideline
I
Fuel connection on fuel pump
-
Mount and tighten screws
Guideline
I
Screw, fuel pump
305314-10
Finishing work
-
Install the fuel tank. (or p. 78)
-
Mount the seat. (or p. 76)
Fuel is poisonous and a health hazard.
Improper handling of fuel is a danger to the environment.
Preparatory work
-
Drain the fuel from the fuel tank into a suitable container.
-
Remove the seat. (or p. 76)
-
Remove the fuel tank. (or p. 76)
0.
points away from the fuel pump.
t)
C,.
O
with the gasket.
@).
I
M8 10 Nm (7.4 lbf ft)
1 5 Nm (11.1 lbf ft)
1
10 Nm (7.4 lbf ft)
I
I 3 Nm (2.2 lbf ft}
EJOT PT ®
81
I