Heartland VALUE Series Assembly Manual page 20

SIDE WALLS INSTALLATION
3" (7,6 cm) x20
2" (5 cm) x70
BEGIN
Stand right sidewall on floor.
It is important to secure the sidewall in the following order.
1
Center sidewall on floor front to back.
Nail the lower sidewall corner to the
backwall trim with one 2" nail (Fig. A).
DOOR
Be sure the measurement between the
2
panel edge and the trim is the same
along the entire length. Then secure
with one 2" nail in the upper corner
(Fig. B).
Nail along the panel edge into the trim
using 2" nails spaced 6" apart.
Nail along bottom of panel using 2"
nails 6" apart. Angle nail to hit floor
frame (Fig. C).
3 Nail down the bottom plate using two 3" nails
between the wall studs.
Screw through the backwall trim into the top and
bottom plates using one 3" screw (Fig. D).
Remove temporary brace.
Repeat process to secure the left sidewall.
3" (7,6 cm) x4
2" (5 cm)
Nail
Fig. A
CENTER
2" (5 cm)
Nail
D O
O R
Panel
Fig. B
6"
(15 cm)
6"
(15 cm)
Fig. C
D O
O R
Fig. D
3" (7,6 cm)
Screw
3" (7,6 cm)
Nail
34
Stand frontwall on floor.
It is important to secure the frontwall in the following order.
1 Center frontwall on floor side-to-side.
Nail the frontwall flush to the floor using
Trim 2" nails 6" apart. Angle nails to hit floor
frame (Fig. A).
Nail the lower sidewall corner to the
frontwall trim with one 2" nail (Fig. B).
Trim
Same
Be sure the measurement between the panel
2
Measurement
edge and the trim is the same along the entire
length. Then secure with one 2" nail in the upper
corner (Fig. C).
Nail along the panel edge into the trim using 2"
nails spaced 6" apart.
2x3"
3" (7,6 cm)
3
Secure the frontwall frame using two 3" screws
Screw
(Fig. D).
Screw through the frontwall trim into the top
and bottom plates using one 3" screw (Fig. E).
Repeat process to secure the right side of
the frontwall.
FRONT WALL INSTALLATION
3" (7,6 cm) x8
2" (5 cm) x38
Trim
6" 6"
(15 cm)
(15 cm)
2" (5 cm)
Nail CENTER
Fig. B
6"
(15 cm)
6"
(15 cm)
3" (7,6 cm)
3" (7,6 cm)
Screw
35
2" (5 cm)
Nail
Fig. A
2" (5 cm)
Nail Trim
Same
Panel Measurement
Fig. C
2" (5 cm)
Nail
2 x 3"
Screw
Fig. E
3" (7,6 cm)
Screw
3" (7,6 cm)
Screw
Fig. D