Carburetor; Clutch - HYOSUNG RX 125 Service Manual

2-9 PERIODIC MAINTENANCE

CARBURETOR

NOTE:
Inspect lnitial 1,000 km and Every 4,000 km.
IDLING ADJUSTMENT
NOTE:
Make this adjustment when the engine is hot.
● Start up the engine and set its speed at any-
where between 1,400 and 1,500 rpm by turning
throttle stop screw ①.
Enginge idle speed
THROTTLE CABLE PLAY
There should be 0.5~1.0 mm play on the throttle
cable. To adjust the throttle cable play.
● Tug on the throttle cable to check the amount of
play.
● Loosen the lock nut ② and turn the adjuster ③
in or out until the specified play is obtained.
● Secure the lock nuts while holding the adjuster
in place.
Throttle cable play

CLUTCH

NOTE:
Inspect lnitial 1,000 km and Every 4,000 km
Clutch play should be 4 mm as measured at the
clutch lever holder before the clutch begins to dis-
engage. If the play in the clutch is incorrect, adjust
it in the following way :
● Loosen the lock nut ④ and screw the adjuster ⑤
on the clutch lever holder all the way in.
● Loosen clutch cable adjuster lock nut ⑥.
● Turn the clutch cable adjuster ⑤ in or out to
acquire the specified play.
● Tighten lock nut while holding the adjuster in
position.
The clutch cable should be lubricated with a light
weight oil whenever it is adjusted.
1,450±100 rpm
0.5~1.0 mm
①
②
③
④
⑤
⑥