Carburetor; Clutch - HYOSUNG GF125 Service Manual

CARBURETOR

Inspect Initial 1,000km and Every 5,000km
IDLING ADJUSTMENT
NOTE:
Make this adjustment when the engine is hot.
● Start up the engine and set its speed at anywhere
between 1400 and 1500r/min by turning throttle stop
screw ①.
Engine idle speed
THROTTLE CABLE PLAY
There shoule be 0.5-1.0mm play � on the throttle cable.
To adjust the throttle cable play.
● Tug on the throttle cable to check the amount of play.
● Loosen the lock nut ② and turn the adjuster ③ in or
out until the specified play in obtained.
● Secure the lock nuts while holding the adjuster in
place.
Throttler cable play

CLUTCH

Inspect Initial 1,000km and Every 5,000km
Clutch play should be 4mm as measured at the clutch
lever holder before the clutch begins to disengage. If the
play in the clutch is incorrect, adjust it in the following
way:
● Loosen the lock nut ② and turn the adjuster ③in or
out until the specified play in obtained.
● Secure the lock nuts while holding the adjuster in
place.
The clutch cable should be lubricated with a light weight
oil whenever it is adjusted.
PERIODIC MAINTENANCE AND TUNE-UP PROCEDURES 2-10
1450±50r/min
0.5-1.0mm
①
→ ←
③ �
②
→ ←
⑤ ④ 4mm