Buell 2007 FIREBOLT Service Manual page 88

HOME
Replacing Oil
1. Inspect drain plug o-ring for tears or damage. Replace if
required. Wipe any foreign material from drain plug.
2. Apply Loctite 565 Thread Sealant, reinstall plug and
tighten to 26-29 ft-lbs (35-39 Nm).
3. Fill oil tank through filler (dipstick) hole with recom-
mended oil from Table 1-5.
NOTE
Oil tank capacity with filter change is approximately 2.5
quarts (2.4 liters) and includes the 4.0 ounces (0.12 liter)
poured into the filter. Always verify proper hot oil level on dip-
stick. Do not overfill.
4. Inspect o-ring on dipstick for rips or tears. Replace as
required.
NOTE
For ease of installation, apply a light film of clean engine oil to
the dipstick o-ring.
5. Install dipstick into oil tank/swingarm fill hole. Make sure
dipstick is installed completely. DO NOT OVER
TIGHTEN.
HARLEY-DAVIDSON TYPE
H.D. Multi-Grade
H.D. Multi-Grade
H.D. Regular Heavy
H.D. Extra Heavy
Table 1-5. Recommended Oil Grades
HARLEY-DAVIDSON
VISCOSITY
SAE 10W40
SAE 20W50
SAE 50
SAE 60
6. Remove left side oil cooler scoop. See
SCOOPS.
1 1
WARNING WARNING
Compressed air can pierce the skin and flying debris
from compressed air could cause serious eye injury.
Wear safety glasses when working with compressed air.
Never use your hand to check for air leaks or to deter-
mine air flow rates. (00061a)
7. Blow out any debris from fins with compressed air from
the inside of the oil cooler outward. Inspect cooler fins for
debris or damage.
8. Wipe up any spilled oil on muffler.
9. Start engine. Verify that oil pressure signal light on instru-
ment support turns off after a few seconds when engine
speed is 1000 RPM or above.
10. Check for oil leaks at oil filter, drain plug, hoses and oil
cooler.
11. Install chin fairing. See
12. Install air scoop. See 2.35 AIR SCOOPS.
13. Check (hot) oil level. See
LOWEST AMBIENT TEMP
RATING °F
HD 360 Below 40
HD 360 Above 40
°
HD 360 Above 60
°
HD 360 Above 80
2007 Buell Firebolt: Maintenance
2.35 AIR
2.33 CHIN FAIRING.
ENGINE OIL LEVEL Check.
COLD WEATHER
STARTS BELOW
50° F
°
(4°C) Excellent
°
(4°C) Good
(16°C) Poor
(27°C) Poor
1-15