Headlight - Buell 2007 FIREBOLT Service Manual

HOME

HEADLIGHT

GENERAL
Dual headlights are equipped with replaceable bulbs. High
beam headlight is located on the left side of vehicle.
High beam headlight turns on and off with headlight
switch.
Low beam headlight is located on the right side of vehi-
cle.
Adjustment of individual headlight projection is accom-
plished by adjusting two screws located in the headlight
support.
For information on headlight housing and bracket disassem-
bly/assembly see 2.25 HEADLIGHT ASSEMBLY AND SUP-
PORT BRACKET.
HEADLIGHT BULBS
Removal
1 1
WARNING WARNING
To prevent accidental vehicle start-up, which could
cause death or serious injury, disconnect negative (-)
battery cable before proceeding. (00048a)
1. Disconnect negative battery cable.
1
CAUTION
Handle bulb carefully and wear eye protection. Bulb con-
tains Halogen gas under pressure, which, if not handled
carefully, could cause serious eye injury. (00062a)
CAUTION
Never touch the quartz bulb. Fingerprints will etch the
glass and decrease bulb life. Grab the bulb with paper or
a clean, dry cloth. Failure to do so could result in bulb
damage. (00210a)
2. See Figure 7-48. Disconnect headlight connection (1).
3. Remove rubber boot from headlight housing.
4. Release wire retaining latch (5) from headlight housing
clips.
5. Pull bulb housing from headlight housing.
7-42 2007 Buell Firebolt: Electrical
8743
4
3
2
1
1. Headlight connection
2. Ground connection
3. Headlight bulb (headlight boot removed)
4. Headlight
5. Wire retaining latch
Figure 7-48. Headlight Bulb
7.12
5