Tips For Self-Help In The Case Of Faults - Meiko EcoStar 545D-M Operating Instructions Manual

Operating instructions EcoStar 545 D-M
Datei:1_EcoStar545D-M_9662798_Betriebsanleitung_EN_2009-05.doc
MEIKO Maschinenbau GmbH & Co. KG, Postfach 2040, D-77652 Offenburg, Tel.: +49/781/203-0, Fax: +49/781/203-1121
13

Tips for self-help in the case of faults

Fault:
Machine does not fill.
Rinse water does not
spray!
Stripes and smears on the
dishes!
Formation of a significant
amount of foam in the
wash tank!
Update:2009-12-18 MRL
W e reserve the right to change execution and construction!
Remedy
• No water available
• Dirt trap blocked
• Level switch defective
• Solenoid valve defective
• Hood safety switch defective
• No water available
• Dirt trap blocked
• Solenoid valve defective
• Booster pump has failed (with air gap)
• Fresh water rinse system furred
• Rinse water mineral content too high (see operating
instructions)
• If this is observed only at particular times, check water
softener for regeneration. This must not carried out
during the dishwashing operation.
• Water pre-treatment defective or not carried out
• Different water type depending on the waterworks
• Unsuitable rinse aid products or wrong dosage quan-
tity
• Detergent for dish-washing by hand enters the wash
tank because of pre-cleaning the dishes
• Daily cleaning is carried out with foaming cleansing
agents which afterwards enter the machine.
• Improve pre-wash, as too much food residue is enter-
ing the tank. Alternatively, empty wash tanks between
uses.
• Rinse water quantity too low
• Detergent or rinse aid product not suitable
• Temperatures too low < 40°C
22/42
9662798