Checking The Rear Brake Fluid Level; Adding Brake Fluid For The Rear Brake - KTM 400 EXC EU Owner's Manual

MAINTENANCE WORK ON CHASSIS AND ENGINE

Checking the rear brake fluid level

9.68
Warning
Danger of accidents Brake system failure.
–
If the brake fluid level falls below the MIN mark, this indicates a leakage in the brake system or worn-out brake linings.
Have the brake system checked in an authorized KTM workshop, and do not ride any further.
Warning
Danger of accidents Reduced braking due to old brake fluid.
–
Have the front and rear brake fluid replaced according to the service plan in an authorized KTM workshop.

Adding brake fluid for the rear brake

9.69
Warning
Danger of accidents Brake system failure.
–
If the brake fluid level falls below the MIN mark, this indicates a leakage in the brake system or worn-out brake linings.
Have the brake system checked in an authorized KTM workshop, and do not ride any further.
Warning
Skin irritations Brake fluid can cause skin irritation on contact.
–
Avoid contact with skin and eyes, and keep out of the reach of children.
–
If brake fluid gets into your eyes, rinse thoroughly with water and contact a doctor immediately.
Warning
Danger of accidents Reduced braking due to old brake fluid.
–
Have the front and rear brake fluid replaced according to the service plan in an authorized KTM workshop.
Warning
Environmental hazard Problem materials cause environmental damage.
–
Dispose of oil, grease, filters, fuel, cleaning substances, brake fluid, batteries, etc. according to regulations.
Info
Never user DOT 5 brake fluid! This is based on silicone oil and is colored purple. Oil seals and brake lines are not designed for
DOT 5 brake fluid.
Avoid contact between brake fluid and painted parts. Brake fluid attacks paint!
Use only clean brake fluid from a sealed container!
–
Hold screw
Guideline
Remaining nuts, chassis
–
Hold push rod
Guideline
Remaining nuts, chassis
–
Reconnect spring
–
Stand the vehicle upright.
–
Check the brake fluid level in the viewer
» When in the viewer
–
Add brake fluid for the rear brake.
400234-10
x
and tighten nut .
 
and tighten nut .
 
.

an air bubble is visible:

M8 30 Nm
(22.1 lbf ft)
M6 15 Nm
(11.1 lbf ft)
.

( p. 61)
x
61