Daewoo Nubira Owner's Manual page 370

ACCUMULATOR SPRINGS INSTALL
CHANNEL PLATE ASSEMBLY
INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . .
MANUAL VALVE INSTALL
CHECKBALLS INSTALLATION
SPACER PLATE AND GASKETS INSTALL
CONTROL VALVE BODY DISASSEMBLE
CONTROL VALVE BODY ASSEMBLE
CONTROL VALVE ASSEMBLY AND
TFP SWITCH INSTALL
WIRING HARNESS ASSEMBLY
CONNECT . . . . . . . . . . . . . . . . . . . . . . . . . . . .
OIL PUMP CLEAN AND INSPECT
OIL PUMP ASSEMBLY INSTALLATION
SIDE COVER/GASKETS, DISASSEMBLE,
ASSEMBLE, INSTALL
OUTPUT SHAFT SLEEVE ASSEMBLE
OUTPUT SHAFT AND SLEEVE
ASSEMBLY INSTALL
SIDE COVER AXLE SEAL INSTALL
STUB SHAFT SLEEVE ASSEMBLE
AND INSTALL . . . . . . . . . . . . . . . . . . . . . . . . .
RIGHT HAND AXLE SEAL ASSEMBLE
VEHICLE SPEED SENSOR
INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . .
INTER 4TH SERVO DISASSEMBLE,
ASSEMBLE, AND INSTALL
LOW/REVERSE SERVO ASSEMBLY
DISASSEMBLE . . . . . . . . . . . . . . . . . . . . . . . .
LOW/REVERSE SERVO ASSEMBLY
ASSEMBLE . . . . . . . . . . . . . . . . . . . . . . . . . . .
OIL FEED PIPES ASSEMBLE
FILTER ASSEMBLY AND SEAL INSTALL
OIL LEVEL CONTROL VALVE INSTALL
OIL PAN AND GASKET INSTALL
TORQUE CONVERTER INSTALLATION
GENERAL DESCRIPTION AND SYSTEM
OPERATION . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DAEWOO V–121 BL4
. . . . . . 5A–255
5A–255
. . . . . . . . . . . . . . . . 5A–256
. . . . . . . . . . . . 5A–256
. 5A–256
. . 5A–258
. . . . . 5A–262
. . . . . . . . . . . . . . . . . 5A–266
5A–267
. . . . . . . . . 5A–268
. . . . 5A–268
. . . . . . . . . . . . . . . . . . 5A–268
. . . . 5A–270
. . . . . . . . . . . . . . . . . . 5A–271
. . . . . . . 5A–270
5A–272
. . . . 5A–272
5A–273
. . . . . . . . . . . . . 5A–273
5A–275
5A–275
. . . . . . . . . . . . 5A–275
. . 5A–276
. . . . 5A–277
. . . . . . . . . . 5A–277
. . . 5A–278
5A–279
4T40–E AUTOMATIC TRANSAXLE 5A – 5
TRANSAXLE DEFINITIONS AND
ABBREVIATIONS . . . . . . . . . . . . . . . . . . . . . .
TRANSAXLE GENERAL DESCRIPTION
TRANSAXLE COMPONENT AND
SYSTEM DESCRIPTION
RANGE REFERENCE CHART
BTSI AND KEY INTERLOCK SYSTEM
AUTOMATIC TRANSMISSION VEHICLE
SPEED SENSOR (A/T VSS)
AUTOMATIC TRANSMISSION INPUT
(SHAFT) SPEED SENSOR (A/T ISS)
SHIFT SOLENOIDS: 1–2 AND 2–3
PRESSURE CONTROL SOLENOID
VALVE (PC SOL. VALVE)
TORQUE CONVERTER CLUTCH
SOLENOID VALVE (TCC SOL. VALVE)
AUTOMATIC TRANSMISSION FLUID
PRESSURE MANUAL VALVE POSITION
SWITCH (TFP VAL. POSITION SW.)
TRANSMISSION FLUID
TEMPERATURE (TFT) SENSOR
TRANSMISSION ELECTRICAL
CONNECTOR . . . . . . . . . . . . . . . . . . . . . . . . .
POWERTRAIN CONTROL
MODULE (PCM) . . . . . . . . . . . . . . . . . . . . . . .
DATA LINK CONNECTOR (DLC)
PCM INPUTS THAT AFFECT THE
4T40–E TRANSMISSION
PARK (ENGINE RUNNING)
REVERSE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
NEUTRAL (ENGINE RUNNING)
OVERDRIVE RANGE – FIRST GEAR
OVERDRIVE RANGE – SECOND GEAR
OVERDRIVE RANGE – THIRD GEAR
OVERDRIVE RANGE – FOURTH GEAR
OVERDRIVE RANGE – 4–3 DOWNSHIFT
MANUAL THIRD – THIRD GEAR
MANUAL SECOND – SECOND GEAR
MANUAL FIRST – FIRST GEAR
5A–279
. . . 5A–280
. . . . . . . . . . . . . . . 5A–280
. . . . . . . . . . . . 5A–283
. . . . . 5A–284
. . . . . . . . . . . . 5A–284
. . . . . 5A–284
. . . . . . . . 5A–285
. . . . . . . . . . . . . . . 5A–285
. . . 5A–286
. . . . . 5A–287
. . . . . . . . 5A–288
5A–289
5A–289
. . . . . . . . . . 5A–290
. . . . . . . . . . . . . . . 5A–290
. . . . . . . . . . . . . . . 5A–291
5A–293
. . . . . . . . . . . 5A–295
. . . . . . 5A–297
. . . 5A–299
. . . . . 5A–301
. . . 5A–303
. . 5A–305
. . . . . . . . . . 5A–307
. . . . . 5A–309
. . . . . . . . . . 5A–311