Mendota Warranty Qualification & Service Reference Form - Mendota DXV-35 DEEP TIMBER II Installation & Operating Instructions Manual

MENDOTA WARRANTY QUALIFICATION & SERVICE REFERENCE FORM
As a part of Mendota's on-going program of customer satisfaction, this Form verifies proper installation and operation. It is important
as a reference for future service. It insures long life and trouble-free operation of Mendota fireplaces & stoves and qualifies the owner
for Mendota's lifetime limited warranty. Owner should sign Form when completed and mail a copy along with Warranty Registration
to Mendota. OPTIONALLY, PLEASE REGISTER AT OUR WEBSITE AT: WWW.JOHNSONGAS.COM/MENDOTA-
REGISTRATION.ASP
HOME OWNER: ________________________________
ADDRESS: ____________________________________
CITY/STATE/ZIP: ______________________________
SIGNATURE: __________________________________
MODEL #: DXV-35
INSTALLED: ___________
Mendota direct vent fireplaces are sophisticated, hi-tech gas appliances. All installation and operating instructions must be carefully
followed. The DXV fireplace must be installed and serviced by a qualified Mendota approved service person.
REF: MENDOTA DXV INSTALLATION MANUAL
APPROVED VENT PIPES AND VENT CAP INSTALLED - Per Manual.
Vent pipes must be fully twist-locked and leak proof.
Check minimum and maximum vertical / horizontal and vent runs.
1000ºsealant must be used on inner joints at adjustable pipe sections
CHECK FOR PROPER CLEARANCES TO COMBUSTIBLES & VENT LOCATIONS - Per Manual
INSTALL PROPER SIZE GAS LINES - CHECK FOR GAS LEAKS - Per Manual
CHECK FOR CORRECT GAS PRESSURE AT MANIFOLD - Per Manual
a. 3.5 Inches Water Column Maximum - Nat. Gas
b. 10.5 Inches Water Column Maximum - L.P. Gas
TAKE COMBUSTION SYSTEM MILLIVOLT READINGS [See Manual PG.. 42]
a. Pilot only - [Minimum Millivolts 325]
b. Main burner operating - [Minimum Millivolts 100]
CYCLE BURNERS ON/OFF FOR PROMPT IGNITION - Per "LIGHTING INSTRUCTIONS"
Burner must light IMMEDIATELY - Flame must travel promptly around "curve" & light burner
INSTALL LOGS AND ADJUST FLAME - Per Manual
Proper pilot flame impingement on thermopile & burner - Air shutter opening: 1/8" - 1/4" Nat. Gas - 1/2" LP
Check that flame is "stable" and is not "lifting" off burner
BRIEF OWNER ON OPERATION AND MAINTENANCE OF UNIT
Light Pilot
Your Name _______________________________________________________________________
Address _________________________________________________________________________
City ________________________________________ State ______Zip ______________________
Dealer (Place of Purchase) ___________________________________________________________
City ________________________________________ State ______Zip ______________________
Date of Purchase _______________________ Serial Number _______________________________
Purchaser's Signature _______________________________________________________________
MENDOTA DXV-35 DIRECT VENT FIREPLACE
CUT OUT PAGE AND MAIL TO: JOHNSON GAS APPLIANCE CO., 520 E AVE. N.W., CEDAR RAPIDS, IOWA 52405
____________________ SERIAL #: ____________________________________
Operate Burner
WARRANTY REGISTRATION
DEALER: _________________________________
ADDRESS: _______________________________
CITY/STATE/ZIP: __________________________
PHONE: __________________________________
.
Reading: ___________________________
Reading: ___________________________
Explain blower "delay" operation
57
DATE
.