Cleaning The Chain; Checking The Chain Tension - KTM 50 SX 2010 Repair Manual

10/REAR WHEEL

Cleaning the chain

12.4
Warning
Danger of accidents Oil or grease on the tires reduces their grip.
–
Remove oil and grease with a suitable cleaning material.
Warning
Danger of accidents Reduced braking efficiency due to oil or grease on the brake discs.
–
Always keep the brake discs free of oil and grease, and clean them with brake cleaner when necessary.
Warning
Environmental hazard Hazardous substances cause environmental damage.
–
Oil, grease, filters, fuel, cleaners, brake fluid, etc., should be disposed of as stipulated in applicable regulations.
Info
The service life of the chain depends largely on its maintenance.

Checking the chain tension

12.5
Warning
Danger of accidents Danger caused by incorrect chain tension.
–
If the chain tension is too high, the components of the secondary power train (chain, engine sprocket, rear sprocket, bear-
ings in transmission and rear wheel) are under additional load. Apart from premature wear, in extreme cases the chain can
rupture or the countershaft of the transmission can break. On the other hand, if the chain is loose, it can fall off the engine
sprocket or the rear sprocket and block the rear wheel or damage the engine. Check the chain tension and correct if neces-
sary.
–
Clean the chain regularly and then treat with chain spray.
Chain cleaner (
Off-road chain spray (
400725-01
–
Jack up the motorcycle. (
–
Push the chain at the end of the chain sliding component upward to measure the
chain tension
Info
The upper chain section
Because chain wear is not always even, repeat this measurement at differ-
ent chain positions.
Chain tension
700483-01 » If the chain tension does not meet specifications:
–
Adjusting chain tension - after checking. (
–
Remove the motorcycle from the work stand. (
p. 140)
p. 141)
p. 7)
.

must be taut.

5... 8 mm (0.2... 0.31 in)
p. 52)
p. 7)
50