Operation - Komatsu 530M Operation & Maintenance Manual

OM2006.2 6/98
Warnings and Cautions
A plate is located next to filler cap on fuel cap which
specifies Diesel Fuel Only. Care should be taken to
open cap slowly and bleed off pressure that may be in
tank when removing filler cap.
Operation and Maintenance Manual refered to is from
Engine Manufacturer.
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Attached to the interior of battery box lid is a DANGER
plate. This plate stresses the need to keep from making
any sparks near the battery. When another battery or
24VDC power source is used for auxiliary power, all
switches must be ''Off'' prior to making any connec-
tions. When connecting auxiliary power cables, posi-
tively maintain correct polarity; connect the positive
(+ ) leads together and then connect the negative (-)
lead of the auxiliary power cable to a good frame
ground. Do not connect to the negative post of the
truck battery or near the battery box. This hookup
completes the circuit but minimizes danger of sparks
near the batteries.
Sulfuric acid is corrosive and toxic. Use proper safety
gear, goggles, rubber gloves and rubber apron when
handling and servicing batteries. Avoid contact with
skin, eyes or clothing. In event of accident, immediately
flush with plenty of water and call a physician. KEEP
OUT OR REACH OF CHILDREN!
These decals are placed on the top of the battery box
and near the battery disconnect switches to indicate
that the battery system (24VDC) is a NEGATIVE (-)
GROUND system.
This decal is placed above the battery disconnect
switches on the right side of the battery box to indicate
''Off'' and ''On'' positions of the switches.
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
A caution plate is located on the side of the battery box.
These instructions must be followed when welding is
done on the truck to avoid damage to the electronic
components.
Safety - Section 2
Page 2-23