MacDon M155 Unloading And Assembly Instructions page 52

PROBLEM
Move GSL to NEUTRAL.
Controls not in Move steering wheel to the locked
NEUTRAL. position.
Disengage header clutch.
Adjust Operator's station position.
Operator's station not
locked.
Ensure lock is engaged.
Neutral interlock
Contact MacDon Dealer.
misadjusted.
Fill empty fuel tank.
No fuel to engine.
Replace clogged filter.
Old fuel in tank. Drain tank, refill with fresh fuel.
Water, dirt or air in
Drain, flush, fill and prime system.
fuel system.
Use proper fuel for operating
Improper type of fuel.
conditions.
Crankcase oil too
Use recommended oil.
heavy.
Have battery tested.
Low battery output.
Check battery electrolyte level.
Battery disconnect
Turn battery switch ON.
switch is OFF.
Poor battery Clean and tighten loose
connection. connections.
Faulty starter. Contact MacDon Dealer.
Wiring shorted, circuit Check continuity of wiring and
breaker open. breaker (manual reset).
Faulty injectors. Contact MacDon Dealer.
GROUND SPEED
mph or kph
ENGINE RPM
ENGINE WARNING LIGHTS
Engine Pre-Heat / Water In Fuel /
Caution / Stop Engine
IGNITION SWITCH POSITIONS
Accessory / Stop / Run / Start
Form 169540
PRE-DELIVERY CHECKS
SOLUTION
DISPLAY
Engine / Windrower Functions
g. Cold Start: engine temperature below 40°F (5°C).
CAUTION
Check to be sure all bystanders have cleared
the area.
1. Follow procedure for Normal Start (on
previous page).
2. Engine will cycle through a period where it
appears to labor until engine warms up.
Throttle is non-responsive during this time
as engine is in "WARM UP" mode. This
mode will last from 30 seconds to 3 minutes
depending on temperature. After engine
has stabilized and idling normally, throttle
becomes active.
Do not operate engine above 1500 rpm until
engine temperature gauge is above 100°F
(37°C).
HAZARD WARNING LIGHTS SWITCH
Activates Hazard Warning Flashers
Cancels Turn Signal
Allows Operator To Select Display Item
Push To SELECT
TURN SIGNAL SWITCHES
Activates Turn Signals On Windrower and Header
Push-ON / Push-OFF
52
NOTE
IMPORTANT
SELECT SWITCH
On Lower Line.
Revision B