Changing The Final Transmission Oil; Replacing The V-Belt; Lubricating The Secondary Sheave - Yamaha N MAX GPD150-A 2015 Service Manual

• Front side cover (right)
Refer to "GENERAL CHASSIS (2)" on page
4-4.
EAS31187

CHANGING THE FINAL TRANSMISSION OIL

1. Stand the vehicle on a level surface.
TIP
• Place the vehicle on the centerstand.
• Make sure the vehicle is upright.
2. Start the engine, warm it up for several min-
utes, and then turn it off.
3. Place a container under the final transmis-
sion.
4. Remove:
• Final transmission oil filler cap "1"
(along with the O-ring "2")
• Final transmission oil drain bolt "3"
(along with the copper washer "4")
Completely drain the final transmission oil.
5. Install:
• Final transmission oil drain bolt
(along with the copper washer
Final transmission oil drain bolt
20 Nm (2.0 m·kgf, 14 ft·lbf)
6. Fill:
• Final transmission oil
(with the specified amount of the recom-
mended final transmission oil)
7. Install:
TIP
Lubricate the O-ring with lithium-soap-based
grease.
8. Start the engine, warm it up for several min-
9. Check:
EAS31188

REPLACING THE V-BELT

1. Remove:
1
2
2. Check:
TIP
Replace the V-belt every 25000 km (15500 mi)
4 3
of operation.
3. Install:
New )
EAS31705

LUBRICATING THE SECONDARY SHEAVE

1. Remove:
3-22
PERIODIC MAINTENANCE
Final transmission oil
Type
Motor oil SAE 10W-30 type SE or
higher or Gear oil SAE 85W GL-3
Quantity
0.15 L (0.16 US qt, 0.13 Imp.qt)
• Final transmission oil filler cap
(along with the O-ring
utes, and then turn it off.
• Final transmission oil leakage
• Air filter case
Refer to "AIR FILTER CASE" on page 7-7.
• V-belt case
Refer to "V-BELT AUTOMATIC TRANSMIS-
SION" on page 5-34.
• V-belt
Damage/wear → Replace.
Grease/oil → Clean the primary and second-
ary pulleys.
Refer to "V-BELT AUTOMATIC TRANSMIS-
SION" on page 5-34.
• V-belt case
Refer to "V-BELT AUTOMATIC TRANSMIS-
SION" on page 5-34.
• Air filter case
Refer to "AIR FILTER CASE" on page 7-7.
• Air filter case
Refer to "AIR FILTER CASE" on page 7-7.
• Secondary sheave assembly
Refer to "V-BELT AUTOMATIC TRANSMIS-
SION" on page 5-34.
New
)