Onboard Charger Repairs; Onboard Charger Removal - Club Car Precedent 2014 Maintenance And Service Manual

31

Onboard Charger Repairs

ONBOARD CHARGER REPAIRS
WARNING
• Knowledge of battery charger wiring and component terminology is required before attempting any
repair (Figure 31-7, Page 31-9).
• Prior to servicing the charger, disconnect the DC plug from the vehicle charger receptacle and the
AC cord from the AC outlet.
NOTE: The onboard charger is available on four-passenger vehicles and is located on the underside of the rear-facing
seat.
This charger has no internals to service or repair. It only has a few external repairs that can be performed.
If an internal component needs repair, the charger must be replaced.
12
11
8
2792

ONBOARD CHARGER REMOVAL

1. If connected, disconnect AC cord (1) from AC outlet (Figure 31-12, Page 31-22).
2. Disconnect the batteries and discharge the controller. See Disconnecting the Batteries – Electric Vehicles
on page 1-4.
3. Lift rear-facing seat bottom (2) and support in the raised position.
4. Disconnect AC cord reel lead (3) from onboard charger (4). Retain sleeve (5).
Page 31-22 2014 Precedent
4
13
5
9
Figure 31-12 Onboard High-Frequency Charger Mounting
® Golf Car Maintenance and Service Manual
BATTERY CHARGER: FOR ERIC CHARG-
10
7
3
ING SYSTEM
1 2