Connecting The Battery - Gasoline Vehicles; Disconnecting The Batteries - Electric Vehicles; Connecting The Batteries - Electric Vehicles - Club Car Precedent 2014 Maintenance And Service Manual

1
General Warnings
2. Disconnect the battery cables, negative (–) cable first, as shown (Figure 1-2).
3. Disconnect the spark plug wire(s) from the spark plug(s).
CONNECTING THE BATTERY – GASOLINE VEHICLES
1. Connect the battery cables, positive (+) cable first.
2. Tighten battery terminals to 80 in·lb (9 N·m).
3. Coat terminals with Battery Terminal Protector Spray (CC P/N 1014305) to minimize corrosion.
4. Connect the spark plug wire(s) to the spark plug(s).
(+)
1
(Viewed from driver side of vehicle)
1. Place TOW/RUN Switch in TOW before disconnecting or connecting
battery cables.
2. Remove negative battery cable.
3. Remove positive battery cable.
Connect battery cables in reverse order.
49A
Figure 1-1 Battery Cable Removal – 6x8-Volt Battery
Configuration
DISCONNECTING THE BATTERIES – ELECTRIC VEHICLES
1. Disable the vehicle. See Disabling the Vehicle on page 1-3.
2. Place Tow/Run switch in the TOW position before disconnecting or connecting the batteries. Failure to heed
this warning could result in a battery explosion or severe personal injury.
3. Disconnect the batteries, negative (–) cable first, as shown (Figure 1-1).
4. After disconnecting the batteries, wait 90 seconds for the controller capacitors to discharge.
CONNECTING THE BATTERIES – ELECTRIC VEHICLES
1. Ensure the Tow/Run switch is in the TOW position.
2. Connect the battery cables, positive (+) cable first.
Page 1-4 2014 Precedent
(–)
® Golf Car Maintenance and Service Manual
(Viewed from driver side of vehicle)
1. Remove negative battery cable.
2. Remove positive battery cable.
Connect battery cables in reverse order.
50
Figure 1-2 Battery Cable Removal – Gasoline
SAFETY
(–)