22
Fuel Pump
FUEL PUMP
See General Warnings on page 1-2.
NOTE: The fuel pump is plastic and cannot be disassembled for repair.
GENERAL INFORMATION
The gasoline vehicle is equipped with an impulse fuel pump. If the fuel pump is not operating properly, perform
the following tests:
• Make sure all hose clamps are tight.
• Inspect the impulse line and fuel lines for damage or clogging.
• Make sure the air vent on the fuel pump is not clogged with dirt.
• Make sure the fuel filter is not clogged.
FUEL PUMP REMOVAL
1.
Turn the key switch to the OFF position and remove the key, place the Forward/Reverse handle in the NEUTRAL
position, and chock the wheels.
2.
Disconnect battery. See Disconnecting the Battery – Gasoline Vehicles, Section 1, Page 1-3.
3.
Turn fuel shut-off valve to the closed (OFF) position (Figure 22-13, Page 22-21).
4.
Disconnect impulse hose (12) from fuel pump (8) (Figure 22-11, Page 22-15).
5.
Disconnect the fuel hoses (10 and 13) from the pump and plug hoses to prevent fuel leakage. See following
WARNING.
WARNING
• Carefully drain any fuel remaining in the pump into an approved container. Add drained fuel back
into fuel tank or dispose of properly.
6.
Remove hardware (11) and fuel pump (8).
FUEL PUMP INSTALLATION
NOTE: This gasoline vehicle complies with the California Air Resources Board (CARB) evaporative emissions
regulations when equipped with MARK 4 DAYPERM C-U-06-030 or AVON GREENBAR G-05-018 fuel
hose (CC P/N 102865101). To remain in compliance with California regulations, replace any fuel hose on
this vehicle with Club Car P/N 102865101 having 'DAYPERM C-U-06-030' or 'AVON GREENBAR G-05-018'
printed on the hose, or equivalent.
1.
Secure fuel pump (8) to vehicle with hardware (11) and tighten to 40 in·lb (4.5 N·m) (Figure 22-11, Page 22-15).
2.
Connect fuel hoses (10 and 13) to fuel pump (8) and secure with clamps. Route the fuel lines as shown.
NOTE: Be sure to connect the fuel line (10), that comes from the fuel filter (7), to the inlet nipple on the pump (8).
Direction of fuel flow is indicated by the arrows on the fuel pump (Figure 22-11, Page 22-15).
3.
Connect the impulse hose (12) to the fuel pump (8) and secure with clamp.
Page 22-16
2014 Precedent
®
Golf Car Maintenance and Service Manual
FUEL SYSTEM