Hyundai 250D-9 Manual page 120

3) 3) STARTING ENGINE IN A COLD WEATHER STARTING ENGINE IN A COLD WEATHER
※
Sound horn to warn surroundings after Sound horn to warn surroundings after
checking if there are obstacles in the area. checking if there are obstacles in the area.
※
Replace the engine oil and fuel referring to Replace the engine oil and fuel referring to
recommended oils at page 7-65. recommended oils at page 7-65.
Fill the anti-freeze solution to the coolant as Fill the anti-freeze solution to the coolant as
required. required.
(1)
Check if the parking brake is locked(With the
parking switch ON).
(2)
Check if the gear selector lever is in the neutral
position.
(3)
Starting the engine while the ambient tempera-
ture is below 0°C.
①
Turn the start key switch to "ON" position.
②
Wait until the gauge of the cluster should be set.
③
Push down the OK symbol (
warmer switch so that it can heat the fuel oil
after the heating pilot lamp (
goes out and then wait for 5 minutes.
④
Turn the start key switch to "Start" position.
⑤
Release the start key switch when the engine is started.
⑥
Keep sufficiently idling condition after starting the engine.
Travelling the machine or operation of the attachments could be caused shut-down of the engine.
※
In the event of the winter season, the fuel oil happens WAX from -6°C. C. In the event of the winter season, the fuel oil happens WAX from -6
When the ambient temperature is below -6°C, do not operate the machine under high load When the ambient temperature is below -6
condition so that it can operate normally the fuel system of the engine, and operate the condition so that it can operate normally the fuel system of the engine, and operate the
machine after keeping idle condition of the engine in a way. machine after keeping idle condition of the engine in a way.
(4) Starting the engine at freeze-up (severe cold winter season) condition.
①
When the ambient temperature is below 0°C, carry out the same method according to above
procedure.
②
Operate the engine in a way so that it can supply a sufficient oil to the engine and hydraulic
system due to heating the oil under low speed and low load condition after starting the engine.
③
At the severe cold condition below -15°C, do not operate the machine under the high load
condition after starting the engine in a way.
Keep the idle condition of the engine for 20~30 minutes at the severe cold condition (freeze-up
condition).
) on the fuel
) on the cluster
C, do not operate the machine under high load
5-12
OFF
ON
START
ON
OFF
110D9OP05