Back Buzzer (Not Hitech) - Valtra 6000 Workshop Manual

BACK BUZZER (AC2), fitting instruction

Back buzzer (not HiTech)

--- The buzzer alarms always when the reverse gear
is engaged (current switched on). The warning
sound is discontinuous.
FITTING:
--- Remove the lever console side panel in the cab.
--- Fasten the buzzer 1 under the rear mudguard fix-
ing bolt. Open the lead---in cover in the bottom of
the lever console so much that the buzzer wire can
be pushed into the console. Connect the wire loom
2 connector (H17) to the buzzer connector
(1a+1b).
--- Fasten wire loom 2 cable shoe under the nut of the
lead---in cover. Pass the wire loom together with
other wires along the lever console lower edge to
the lower part of the gear levers.
--- Fasten switch 6 onto support 5 (washers 7 on both
sides of the support).
Unscrew a screw lever bracket screw on the
driver's seat side of the bracket and fasten the sup-
port under the screw.
Adjust the switch so that it functions when the
reverse gear is engaged (if the support cannot be
adjusted enough, change places of the washers
between the switch and the support).
--- Connect the wire 2 loom to the switch pin.
Tractors --->668102: Connect the wire 2A to the
another switch pin and pass wire no 210 (green)
with other wires under the floor mat into the steer-
ing wheel console. Fasten the wire on the tractor
wire loom e.g. with tape.
Disconnect the fuse box connector X4. Connect
the wire loom connector to pin no 4 of the con-
nector X4.
--- Tractors 668103--->: Connect the connector S27
(green wires no 210) in the cab harness to the
another pin of the switch.
--- Rebuild the tractor. Check the function of the buz-
zer.
1 33039300 Per.summeri.
1 1 33006300 .Per.summeri
2 1 33044600 .Johdinsarja
3 1 SA1509 .Liitinkotelo
4 1 SA1518 .Liitin
5 1 33039100 .Kannatin
6 1 31355810 .Rajakytkin
7 2 JD0412 .Aluslevy
8 1 JB0981 .Mutteri
. . . . . . . . . 33039300
Backsummer Back buzzer
Backsummer Back buzzer
Ledningssats Wiring set
Skarvhus Connector
Anslutning Connection
Hållare Support
Gränsbrytare Limit switch
Bricka Washer
Mutter Nut
23.12.1994
09.03.2000
R.fahrsummer Avertisseur arrière
R.fahrsummer Avertisseur arrière
Verkabelung
Steckdose
Anschluß
Halter
Grenzschalter
Scheibe
Mutter
565
Code
Model
39.16
6000---8750
Jeu de câbles
Raccord
Raccord
Support
Interrupteur limitation
Rondelle
Ecrou
Page
1 (2)