Table Of Contents - Valor L2 1700KN Installation Manual

Welcome to Valor
This appliance has been professionally installed by:
Dealer Name: ________________________________
Phone:______________________________________
Fireplace Safety ................................................. 4
Specifi cations ..................................................... 6
Kits & Accessories .............................................. 7
Dimensions & Location ..................................... 8
Installation Planning ......................................... 9
Before Installing ............................................................9
Overview ......................................................................10
Mantel Clearances ......................................................11
Framing .........................................................................13
Wall Finish ....................................................................16
Material Specifications ..............................................16
Non-Combustible Cement Board ............................16
Avoiding Cracking Wall Finishes ...............................18
Venting .............................................................. 19
Overview ......................................................................19
Co-Axial ....................................................................... 20
Typical Co-axial Venting Components ....................20
Venting Chart ..............................................................21
Restrictor Settings .....................................................22
Horizontal Vent Termination ....................................23
Vertical Vent Termination .........................................24
Co-Linear Conversion ................................................ 25
Installation into existing fireplace cavity ................25
Installation partially into fireplace cavity ...............26
Installation into existing adjacent chimney ...........27
Example of co-linear conversion accessories........28
Installation ....................................................... 29
Appliance Preparation .............................................. 29
Unpack Appliance ......................................................29
Fit Standoffs ................................................................29
Remove Heat Shield ...................................................29
Convert from Top to Rear Outlet (if required) .......30
Fit Appliance into Framing ........................................31
Remove Window ........................................................32
®
Please read this manual
installing and operating this
appliance.
HeatShift™ System-if used .................................... 33
Install HeatShift Take-Off Collars to Appliance .....33
Remove Convection Baffle .......................................33
Electrical Wiring ......................................................... 34
Gas Supply ................................................................... 36
Liners ........................................................................... 38
Fuel Beds ..................................................................... 40
Driftwood Kit 1705DWK ........................................... 40
Decorative Glass Murano 1700DGM.......................43
Rocks & Shale Set 1714RSS ...................................... 44
Split Wood Kit 1700SWK ............................................47
Birch Log Kit 1700BLK ................................................50
Window Re-Installation & Checking ....................... 53
Wall Switch .................................................................. 54
Remote Control Pairing ............................................. 56
Checking Operation and Aeration .......................... 58
Trim & Barrier Screen ................................................ 59
Wiring Diagram ................................................ 60
Approved Venting Components .................... 61
Commonwealth of Massachusetts ............... 63
Appendix A-Lighting Instructions ............... 65
Appendix B-Remote Control Operation .... 66
Appendix C-Wall Switch Operation ............ 73
Appendix D-HeatShift™System .................. 74
Appendix E-Spare Parts ............................... 94
BEFORE
3