Engine - Suzuki EN125-2A Service Manual

PERIODIC LUBRICATION CHART
The maintenance schedule, which follows, is based on this philosophy. It is timed by odometer indication,
and is calculated to achieve the ultimate goal of motorcycle maintenance in the most economical manner.
Interval
ltem
Throttle cable
Throttle grip
Clutch cable
Speedometer cable
Speedometer gear box
Tachometer cable
Drive chain
Brake pedal
Brake cam shaft
Steering stem bearings
Swing arm bearings
WARNING:
Be careful not to apply too much grease to the brake cam shafts. If grease gets on the linings,
brake slippage will result.
Lubricate exposed parts which are subject to rust, with either motor oil or grease whenever the motorcycle
has been operated under wet or rainy conditions.
Before lubricating each part, clean off any rusty spots and wipe off any grease, oil, dirt or grime.
PERIODIC MAINTENANCE AND TUNE-UP PROCEDURES
Initial and Every 6 000 km
Km
Months
Engine oil
Engine oil
Grease or engine oil
6
-
-
-
-
Engine oil every 1 000 km
-
Grease every 2 years or 20 000 km
2-2
Every 12 000 km
12
-
Grease
-
Grease
Grease
Grease
-
Grease