Engine Oil Filter; Oil Pressure; Oil Sump Filter - Suzuki EN125-2A Service Manual

2-9 PERIODIC MAINTENANCE AND TUNE-UP PROCEDURES

ENGINE OIL FILTER

Replace initial 1 000 km and Every 4 000 km
Replace the oil filter in the following manner:
Drain engine oil by removing the drain plug.
Remove the three screws securing the filter cap.
Take off the cap, and pull out the filter.
Replace the filter with a new one.
Before installing on the filter, check to be sure
that the O-ring is properly installed.
Before putting on the filter cap, check to be sure
that the filter spring
installed correctly.
Replace the filter cap and tighten the screws
securely.
Pour in engine oil and check the level.
NOTE:
Pour about 1,150 ml of engine oil into the
engine only when changing oil and replacing
oil filter at the same time.
When performing engine overhaul, the
amount of oil to be replenished is 1,350 ml.
CAUTION:
When reassembling the oil filter, make sure
to check the oil filter installed as shown in
illustration. If the filter is installed improperly,
serious engine damage may result.

OIL PRESSURE

Inspect Every 4 000 km
Refer to page 3-1.

OIL SUMP FILTER

Clean Every 8 000 km
Clean the sump filter screen to remove any foreign
matter that may be collected there. Inspect the
screen to insure that it is free of any sign of damage.
and the O-ring are
1
2
3