Fuel System And Air Intake; Fuel System; Fuel Tank Vent Line; Fuel Pump / Fuel Filters - Polaris 2014 RZR XP 1000 Service Manual

5. Thread the upper or lower jam nut as required to
obtain proper cable adjustment.
NOTE: This procedure may require a few
attempts to obtain the proper adjustment.
6. Once the proper adjustment is obtained, place the
shift cable and upper jam nut into the mount. Tighten
the lower jam nut against the mount.
7. Start engine and shift through all gears to ensure the
shift cable is properly adjusted. If transmission still
ratchets after cable adjustment, the transmission will
require service.
9924874 R02 - 2014 RZR XP / XP 4 1000 Service Manual
© Copyright 2013 Polaris Industries Inc.

FUEL SYSTEM AND AIR INTAKE

Fuel System

WARNING
Gasoline is extremely flammable and explosive under
certain conditions.
Always stop the engine and refuel outdoors or in a well
ventilated area.
Do not smoke or allow open flames or sparks in or near
the area where refueling is performed or where
gasoline is stored.
Do not overfill the tank. Do not fill the tank neck.
If you get gasoline in your eyes or if you swallow
gasoline, seek medical attention immediately.
If you spill gasoline on your skin or clothing,
immediately wash it off with soap and water
and change clothing.
Never start the engine or let it run in an enclosed area.
Engine exhaust fumes are poisonous and can result in
loss of consciousness or
death in a short time.
Never drain the fuel when the engine is hot.
Severe burns may result.

Fuel Tank Vent Line

Symptoms of a restricted fuel tank vent include the
following: collapsing fuel tank, engine miss or hesitation,
loss of engine performance
temperatures.
1. Remove the seats and the engine service panel.
2. Check the fuel tank vent line for signs of wear,
deterioration or damage. Replace vent line if
necessary.
3. Be sure the vent line is routed properly and secured
with cable tie(s).
NOTE: Make sure vent line is not kinked or
pinched.

Fuel Pump / Fuel Filters

The fuel pump assembly (Item 1) is located in the fuel
tank under the passenger seat.
The RZR XP 1000 EFI engine uses a serviceable, high-
volume, high-pressure, fuel pump that includes a
preliminary filter (Item 2) and an internal fine filter (Item
3) located before the pump regulator.
MAINTENANCE
2
or high exhaust
2.11