Fuel System And Air Intake; Fuel System; Fuel Line; Fuel Pump / Fuel Filters - Polaris 2008 RZR Service Manual

6. Once the proper adjustment is obtained, place the shift
cable and upper jam nut into the mount. Tighten the lower
jam nut against the mount.
7. Start engine and shift through all gears to ensure the shift
cable is properly adjusted. If transmission still ratchets
after cable adjustment, the transmission will require
service.

FUEL SYSTEM AND AIR INTAKE

Fuel System

WARNING
Gasoline is extremely flammable and explosive
under certain conditions.
Always stop the engine and refuel outdoors or in
a well ventilated area.
Do not smoke or allow open flames or sparks in
or near the area where refueling is performed or
where gasoline is stored.
Do not overfill the tank. Do not fill the tank neck.
If you get gasoline in your eyes or if you swallow
gasoline, seek medical attention immediately.
If you spill gasoline on your skin or clothing,
immediately wash it off with soap and water
and change clothing.
Never start the engine or let it run in an enclosed
area. Engine exhaust fumes are poisonous and
can result loss of consciousness or death
in a short time.
Never drain the fuel when the engine is hot.
Severe burns may result.

Fuel Line

1. Check the quick-connect fuel line for signs of wear,
deterioration, damage or leakage. Replace if necessary.
Fuel Line
2.
IMPORTANT: Make sure line is not kinked or pinched.
3.

Fuel Pump / Fuel Filters

The 800 EFI RZR engine uses a non-serviceable, high-volume,
high-pressure, fuel pump that includes a preliminary filter and
an internal fine filter located before the pump regulator.
NOTE: Neither filter is servicable.
NOTE: For all other information related to the EFI
Injector Rail
System, refer to Chapter 4.
Connector

Vent Lines

1.
Fuel Pump
Connector
2.
IMPORTANT: Ensure lines are not kinked or pinched.
Be sure fuel line is routed properly.
Replace fuel line every two years.
Fuel Pump Asm
Fuel Pump Asm
Located in Fuel Tank
Preliminary Filter
Check fuel tank, front gear case, rear gear case and
transmission vent lines for signs of wear, deterioration,
damage or leakage. Replace every two years.
Be sure vent lines are routed properly and secured with
cable ties.
MAINTENANCE
Fine Filter
2.11
2