Fuel System; Fuel Tank Vent Line; Fuel Pump / Fuel Filter - Polaris 2015 RZR 900 Service Manual

MAINTENANCE

FUEL SYSTEM

Fuel System
WARNING
Gasoline is extremely flammable and explosive under
certain conditions.
Always stop the engine and refuel outdoors or in a well
ventilated area.
Do not smoke or allow open flames or sparks in or near
the area where refueling is performed or where
gasoline is stored.
Do not overfill the tank. Do not fill the tank neck.
If you get gasoline in your eyes or if you swallow
gasoline, seek medical attention immediately.
If you spill gasoline on your skin or clothing,
immediately wash it off with soap and water
and change clothing.
Never start the engine or let it run in an enclosed area.
Engine exhaust fumes are poisonous and can result in
loss of consciousness or
death in a short time.
Never drain the fuel when the engine is hot.
Severe burns may result.

Fuel Tank Vent Line

Symptoms of a restricted fuel tank vent include the
following: collapsing fuel tank, engine miss or hesitation,
loss of engine performance
temperatures.
1. Remove the seats and the engine service panel.
2. Check the fuel tank vent line for signs of wear,
deterioration or damage. Replace vent line if
necessary.
3. Be sure the vent line is routed properly and secured
with cable tie(s).
NOTE: Make sure vent line is not kinked or
pinched.
2.10

Fuel Pump / Fuel Filter

The fuel pump assembly
under the passenger seat.
The RZR 900 EFI engine uses a serviceable, high-
volume, high-pressure, fuel pump that includes a
preliminary filter
before the pump regulator.
NOTE: Neither filter is serviceable individually. Must
replace the fuel pump as an assembly.
or high exhaust
Refer to Chapter 4 for Fuel Pump Replacement,
page 4.22 and all other information related to the EFI
System.
9925723 R01 - 2015 RZR 900 Service Manual
© Copyright 2014 Polaris Industries Inc.
is located in the fuel tank
1
and an internal fine filter located