Lubrication And Maintenance Chart - New Holland T6010 Operator's Manual

Service Operation
Interval No.
1
When warning When warning
2
lamp lights lamp lights
3
4
5
Every 10 hours y
or daily
6
7
8
9
Every 50 hours Every 50 hours
10
11
Every 100 hours
12
*13
14
Every 300 hours Every 300 hours
15
16
17
#18
19
20
Every 600 hours Every 600 hours
21
22
23
24
25
26
Every 1200 hours Every 1200 hours
or annually y 27
28
29
30
31
Every 1200 hours Every 1200 hours
or two years y 32
33
34
Every 1800 hours
35
Every Three Years
36
37
38
39
40
General General
41
Maintenance Maintenance
42
43
44
45
46
* Batteries on tractors operating in temperate climates need only be checked every 1200 hours. See Operation 29.
# Oil and filter change interval will be reduced if the diesel fuel has a high sulphur content or if the tractor is operated in
extremely cold temperatures.
4--10
SECTION 4 - - LUBRICATION AND MAINTENANCE

LUBRICATION AND MAINTENANCE CHART

Maintenance Requirement
Engine air cleaner outer element
Brake fluid level
Fuel system water separator
Engine coolant level
Engine oil level
Windscreen washer reservoir (where fitted)
Air reservoir(s) trailer brakes (where fitted)
Radiator,oil cooler and air conditioner condenser
Cab air filters
All grease fittings
A/C & Brake Compressor drive belts (where
fitted)
Poly V--belt
Battery electrolyte level (tropical climates)
4WD suspension cylinder upper bearing
Transmission/rear axle/hydraulics oil level
Parking brake
Front P.T.O. gearbox oil level (where fitted)
Engine oil and filter
Hydraulic and transmission oil filters
Air cleaner outer element
Engine air intake connections
Fuel Pre--filter and fuel filter elements
Four wheel drive front axle and hubs oil level
Cab air filters
Transmission/rear axle/hydraulic oil and filter
Four wheel drive axle differential oil
Four wheel drive axle hub oil
Front P.T.O gearbox oil
Battery electrolyte level (temperate climates)
Engine coolant
Engine air cleaner inner element
Check and adjust tappet clearance
Air brake drier reservoir
Fuel injectors
Air Conditioner System
Bleeding the fuel injection system
Footbrakes
Front and rear wheel nut torque
Tyre pressures and condition
Engine idle speed
Automatic pick--up hitch
Remote control valve drain bottle(s)
Headlight and worklamp adjustment
Bulb replacement
Fuse replacement
Cleaning the tractor
X X
X X
X
X X
X X
X X
X
X X
X X
X
X X
X X
X X X
X
X X
X X
X
X
X
X
X
X X
X X
X
X
X
X
X
X X X
X
X
X X
X
X X X
X X X
X X
X X
X X
X X
X X
X X
X
X X
X X
X X
X X
4--11
4--13
X 4--13
4--14
4--15
4--15
X 4--16
4--17
4--18
4--20
4--26
4--27
4--27
4--28
4--29
4--30
4--30
4--31
4--33
4--34
4--34
4--35
4--37
4--38
4--39
4--40
4--41
4--41
4--42
4--43
4--47
4--48
4--49
4--50
4--51
4--52
4--52
4--53
4--53
4--54
4--55
4--56
4--57
4--58
4--62
4--72