Checking The Air Filter Element - Yamaha MT-03 Service Manual

NOTE:
If the specified clutch cable free play cannot be
obtained on the handlebar end of the cable, ad-
just the free play at the engine end of the cable
using the adjusting nut.
Engine end
a. Loosen the locknut "1".
b. Turn the adjusting nut "2" in direction "a" or
"b" until the specified clutch cable free play
is obtained.
Direction "a"
Clutch cable free play is increased.
Direction "b"
Clutch cable free play is decreased.
b
a
1 2
1
c. Tighten the locknuts.
EAS00086

CHECKING THE AIR FILTER ELEMENT

NOTE:
There are two check hoses "1" and "2" at the
bottom of the air filter case. Check the hose "1"
for accumulated dirt, water or oil. If dirt, water
or oil is visible remove the hose, clean it and
then install it in its original position. Remove the
plug "3" drain any dirt, water or oil and then in-
stall it in its original position. If dust and/or wa-
ter collects in these hoses, clean the air filter
element and air filter case.
1
1. Remove:
• Air filter case cover "1"
2. Remove:
• Air filter element "1"
1
3. Check:
• Air filter element
Damage Replace.
4. Install:
• Air filter element
CAUTION:
Never operate the engine without the air fil-
ter element installed. Unfiltered air will
cause rapid wear of engine parts and may
damage the engine. Operating the engine
without the air filter element will also affect
the throttle body tuning, leading to poor
engine performance and possible over-
heating.
3-12
ENGINE
1