Carburetor - HYOSUNG COMET 125 Service Manual

2-7 PERIODIC MAINTENANCE
Clean the air cleaner element for the following:
When the air cleaner element clean with the air gun,
necessarily blow at the inside by compressed air.
Carefully examine the air cleaner element for tears during
cleaning. Replace it with a new one if it is torn.
Assemble the element completely or damage severely
the engine.
Be careful not to allow water to go inside the air clea-
ner element.

CARBURETOR

Inspect Interval
Inspect Initial 1,000 km and Every 4,000 km.
IDLE SPEED
CAUTION
Make this inspection when the engine is hot.
Connect an engine tachometer to the high tension
cord.
Start up the engine and set its speed at anywhere
1,450 and 1,550 rpm by turning throttle stop screw
Engine idle speed
Engine tachometer : 09900 - 26006
THROTTLE CABLE PLAY
There should be 0.5 1.0 mm play on the throttle cable.
To adjust the throttle cable play.
Tug on the throttle cable to check the amount of play.
Loosen the lock nut
out until the specified play is obtained.
Secure the lock nuts while holding the adjuster in
place.
Throttle cable play
1,450 1,550 rpm
and turn the adjuster
0.5 1.0 mm (0.02~0.04 in)
More frequent servicing may be performed on mo-
torcycles that are used under severe condi-
tions, also clean the air cleaner element when
replacing the oil to prevent damage of the engine.
.
in or
CAUTION