Figure Grid No; Removal Of Rectifier End Shield Bearing; Testing Rotor For Open Or Shorts; Installation Of Rectifier End Shield Bearing - Piper CHEROKEE WARRIOR PA-28-151 1995 Maintenance Manual

PIPER CHEROKEE WARRIOR SERVICE MANUAL
Figure
11-29.

Removal of Rectifier End Shield Bearing............................................................................................

11-30. Testing Rotor for Ground.....................................................................................................................
11-31.

Testing Rotor for Open or Shorts.........................................................................................................

11-32. Installation of Grease Retainer.............................................................................................................
11-33.

Installation of Rectifier End Shield Bearing........................................................................................

11-34. Installation of Drive End Shield Bearing.............................................................................................
11-35. Installation of Pulley ............................................................................................................................
11-36. Installation of Insulators Assembly......................................................................................................
11-37 Installation of Positive Rectifier...........................................................................................................
11-38. Installation of Capacitor.......................................................................................................................
11-39. Installation of Battery Output Insulator ..............................................................................................
11-40. Installation of Negative Rectifier Assembly........................................................................................
11-41. Installation of Stator.............................................................................................................................
11-42. Battery Installation - 12 Volt (Warrior/Warrior II)..............................................................................
11-43. Battery Installation - 24 Volt (Warrior III S/N's 2816110).................................................................
11-44. Lamar 14 Vdc Regulator Check...........................................................................................................
11-45. Lamar 28 Vdc Regulator Check...........................................................................................................
11-46. Application of Wico Overvoltage Control...........................................................................................2F2011-47.
Lamar 14 Vdc System Overvoltage Check...........................................................................................................
11-48.

Lamar 28 Vdc System Overvoltage Check..........................................................................................

11-49. Exploded View of Gear Reduction Starter Motor................................................................................
11-50. Turning Starting Motor Commutator...................................................................................................
11-51 Testing Motor Armature for Shorts......................................................................................................
11-52. Testing Motor Fields for Grounds........................................................................................................
11-53.

No Load Test Hookup..........................................................................................................................

11-54. Stall Torque Hookup............................................................................................................................
11-55. Strobe Light Connections (Warrior/Warrior II)...................................................................................
11-56. Strobe Light Connections (Warrior II).................................................................................................
11-57 Strobe Light Connections (Warrior III) ...............................................................................................
11-58. Annunciator Panel (Warrior/Warrior II)..............................................................................................
11-59. Annunciator Panel (Warrior III)...........................................................................................................
11-60. Ignition Switch Wire Position..............................................................................................................

See Section XI. Electrical Charts and Wiring Diagram Index for 11-61 thru 11-128........................

12-1. Two Year, Magnesium Battery Connection.........................................................................................
12-2.

Garrett ELT's Schematic......................................................................................................................

12-3. Communications Components ELT Schematic. ..................................................................................
12-4.

Narco ELT 10 Schematic (Prior to S/N 2816053)..............................................................................

12-5

Narco ELT 10 Schematic (2816053 to 2816093) ...............................................................................

12-6 ELT Portable Folding Antenna (Narco)...............................................................................................
12-7. ELT Using Fixed Aircraft Antenna (Narco)........................................................................................
12-8. Narco ELT 910 Emergency Locator Transmitter Schematic ..............................................................
12-9. ELT 910 Battery Pack..........................................................................................................................
12-10.

Artex 11 ELT .......................................................................................................................................

12-11.

Artex ELT 110 Wiring Schematic .......................................................................................................

13-1. Cabin Heater, Defroster and Fresh Air System....................................................................................
Revised: February 28, 1995
LIST OF ILLUSTRATIONS (cont.)
2A7
Island Enterprises
Aerofiche
Grid No.
2E22
2E23
2E23
2E24
2E24
2F1
2F1
2F1
2F1
2F3
2F3
2F3
2F3
2F7
2F10
2F17
2F18
2F21
2F21
2F23
2G1
2G1
2G3
2G3
2G3
2G9
2G10
2G11
2G15
2G15
2G21
2H5
2J15
2J15
2J17
2J19
2J19
2J20
2J20
2J22
2J23
2J24
2K1
2K7