Piper CHEROKEE WARRIOR PA-28-151 1995 Maintenance Manual page 257

PIPER CHEROKEE WARRIOR SERVICE MANUAL
o. Assemble the rotor gear onto the rotor, making sure the key slot of the gear fits into the cam slot of
the rotor. Tap with a light hammer until the gear bottoms on the shaft.
p. Time the magneto internally by placing the magneto on the T-100 assembly and timing tool hole.
(Refer to Figure 8-13.) Make sure the coupling lugs are in the slots of the index plate. Swing the frame
c o u nterclockwise against the pin to line up the rotor and cam for E gap position.
q. Attach either the red or green wire of the timing light to the bronze point terminal and the black
wire to the frame of the magneto. (Refer to Figure 8-13.) With a screwdriver, adjust the points so the timing
light indicates point openings. Check thats points are open to gap of 0.008 - 0.010 inch. Secure the points by
tightening the screws. Attach the coil wire to the vertical bronze male terminal of the point assembly.
1. TIMING LIGHT
2. RED OR GREEN WIRE
3. BLACK GROUND WIRE
4. VENT
r. Assemble the condenser into the distributor housing, being careful to rotate the condenser wire the
same rotation as the condenser is tightened in the housing. Torque to 110 in. lbs. Assemble the distributor gear
in the distributor block, with the L and R facing you. Assemble the bearing bar to the distributor block so that
the open side of the dust collector is toward the air vent and hood. Assemble the distributor block in the
d i stributor housing, with the cut-away toward the condenser. Use screws and lock washers. Torque to 18-20 in.
lbs.
s. Connect the condenser wire to the slip terminal on the point assembly. Align the L or R (depend-
ing on magneto rotation) on the rotor gear so it points toward the high tension lead of the coil.
t. Align the L or R on the distributor gear with the L or R on the distributor block and insert the tim-
ing pin (T-118) through the block into the gear.
Revised: February 28, 1995
Effectivity
Figure 8-13. Timing Magneto Internally and Assembly
1K17
Island Enterprises
POWER PLANT
Magneto (SLICK)