Table of Contents
Advertisement
PIPER CHEROKEE WARRIOR SERVICE MANUAL
C. CABIN GROUP (cont.)
20. On Warrior II models only, inspect condition of air conditioning ducts. .............
21. On Warrior II models only, remove and clean air conditioning evaporator
filter. .....................................................................................................................
D. FUSELAGE AND EMPENNAGE GROUP
1. Remove inspection plates and panels....................................................................
2. Inspect baggage door latch and hinges for operation and security........................
3. Inspect battery, box and cables (Inspect at least every 30 days. Flush box as
required and fill battery per instructions on box. .................................................
4. Inspect electronic installations. ............................................................................
5. Inspect bulkheads and stringers for damage. .......................................................
6. Inspect condition and security of antenna mounts and electric wiring. ...............
7. On Warrior II models only, inspect air conditioning system for freon leaks. ......
8 . On Warrior II models only, check freon level in sight gauge of receiver-d e h ydrator
(refer to Section XIV). .........................................................................................
9 . On Warrior II models only, inspect air conditioner condenser air scoop rigging. . . . . .
10. Inspect fuel lines, valve and gauges for damage and operation. (See Note 8.)....
11. Clean screens in fuel pumps. ................................................................................
12. Remove, drain, and clean fuel strainer bowl and screen. Drain and clean at
least every 90 days. ..............................................................................................
13. Inspect security of all lines. .................................................................................
14. Inspect vertical fin and rudder surfaces for damage. ...........................................
15. Inspect rudder hinges, horn and attachments for damage and operation..............
1 6 . Inspect rudder control stop to insure stop has not loosened and lock nut is tight.. . . . .
17. Inspect vertical fin attachments. ...........................................................................
18. Inspect rudder hinge bolts for excess wear. Replace as required. .......................
19. Inspect stabilator surfaces for damage. ................................................................
2 0 . Inspect stabilator, tab hinges, horn and attachments for damage and operation. . . . . . .
21. Inspect stabilator control stops to insure stop has not loosened and lock nut is
tight. .....................................................................................................................
22. Inspect stabilator attachments. .............................................................................
23. Inspect stabilator and tab hinge bolts and bearings for excess wear. Replace as
required. ...............................................................................................................
24. Inspect stabilator trim mechanism. ......................................................................
25.Check all cable tensions by using a tensiometer. (See Note 17.) ..........................
26. Inspect aileron, rudder, stabilator, stabilator trim cables, turnbuckles, guides
and pulleys for safety, damage and operation. .....................................................
27.Clean and lubricate stabilator trim drum screw. ....................................................
28. Clean and lubricate all exterior needle bearings. .................................................
29. Lubricate per lubrication chart. ............................................................................
30. Inspect strobe light for security and operation. ....................................................
Revised: February 28, 1995
TABLE III-I. INSPECTION REPORT (cont.)
Nature of Inspection
1D22
Island Enterprises
Inspection time (hrs)
50 100 500 1000
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
INSPECTION
Advertisement
Chapters
Table of Contents
Troubleshooting
