Piper CHEROKEE WARRIOR PA-28-151 1995 Maintenance Manual page 197

PIPER CHEROKEE WARRIOR SERVICE MANUAL
TABLE V-III. SURFACE CONTROLS TROUBLESHOOTING CHART (cont.)
Trouble
Excessive resistance to rudder
pedal movement. (cont.)
Rudder pedals not neutral when
rudder is streamlined.
Incorrect rudder travel.
Trouble
Trim control knob moves with
excessive resistance.
Trouble
Flaps fail to extend or retract.
Flaps not synchronized or fail to
move evenly when retracted.
Revised: February 28, 1995
RUDDER CONTROL SYSTEM (cont.)
Cause
Cables not in place on pulleys.
Cables crossed or routed
i n c o rrectly
Rudder cables incorrectly rigged.
Rudder bellcrank stop incorrectly
adjusted.
Nose wheel contacts stops before
rudder.
RUDDER TRIM CONTROL SYSTEM
Cause
System not lubricated properly.
FLAP CONTROL SYSTEM
Cause
Control cable broken or
d i s c o n n e c t e d .
Incorrect rigging of system.
THIS SPACE INTENTIONALLY LEFT BLANK
1I5
Island Enterprises
Remedy
Install cables correctly. Check
cable guards.
Check routing of control cables.
Rig in accordance with
Paragraph 5-32.
Rig in accordance with
Paragraph 5-32.
Rig in accordance with
Paragraph 5-32.
Remedy
Lubricate system per Lubrication
Chart in Section II of this manual.
Remedy
Replace or reconnect control
cable. (Refer to Paragraph 5-39.)
Adjust flaps per in structions in
Paragraph 5-40.
SURFACE CONTROLS