Table of Contents
Advertisement
14 ELECTRICAL SYSTEM
14.3
88
Charging the 12-V battery
Warning
Risk of injury Battery acid and battery gases cause serious chemical burns.
–
Keep 12 V batteries out of the reach of children.
–
Wear suitable protective clothing and safety glasses.
–
Avoid contact with battery acid and battery gases.
–
Keep sparks or open flames away from the 12 V battery.
–
Only charge 12 V batteries in well-ventilated rooms.
–
Rinse the affected area immediately with plenty of water in the event of contact with the skin.
–
Rinse eyes with water for at least 15 minutes and consult a doctor immediately if battery acid and battery
gases get into the eyes.
Note
Environmental hazard 12 V batteries contain environmentally hazardous materials.
–
Do not dispose of 12 V batteries as household waste.
–
Dispose of 12 V batteries at a collection point for used batteries.
Note
Environmental hazard Hazardous substances cause environmental damage.
–
Dispose of oils, grease, filters, fuel, cleaning agents, brake fluid, etc., correctly and in compliance with the appli-
cable regulations.
Info
Even when there is no load on the 12-V battery, it discharges steadily each day.
The charging level and the method of charging are very important for the service life of the 12-V battery.
Rapid recharging with a high charging current shortens the service life of the battery.
If the charging current, charging voltage, or charging time is exceeded, electrolyte escapes through the safety
valves. This reduces the capacity of the 12-V battery.
If the 12-V battery is discharged by repeated starting, charge the 12-V battery immediately.
If the 12-V battery is left in a discharged state for an extended period, it will become deeply discharged and sulfat-
ing occurs, thus destroying the battery.
The 12-V battery is maintenance-free. The acid level does not have to be checked.
Preparatory work
–
Remove the seat. (
–
Remove the 12-V battery.
Main work
–
Connect a battery charger to the 12-V battery. Switch on the battery
charger.
Guideline
The battery charger must be suitable for the 12-V battery.
Info
Never remove cover
Charge the 12-V battery to a maximum of 10% of the capac-
V02752-10
ity specified on battery housing
–
Switch off the battery charger after charging and disconnect from
the 12-V battery.
p. 53)
(
p. 86)
1
.
2
.
Advertisement
Table of Contents
