Warranty Certificate K21/K25 Engines (2017) - UniCarriers 1F1 Operator's Manual

UniCarriers Americas Corporation
Global Component Technologies Corporation
CALIFORNIA AND U.S. FEDERAL EMISSION CONTROL WARRANTY STATEMENT
The following statement is required to be provided by regulations of the California Air Resources Board and US Environmental Protection Agency.
Note: This 'Emission Warranty Statement' is in addition to the "Limited Warranty" statement
provided with the subject forklift truck supplied by UniCarriers Americas Corporation ("UCA") and
engine supplied by Global Component Technologies Corporation ("GCT").
YOUR WARRANTY RIGHTS AND OBLIGATIONS
The California Air Resources Board ("ARB") and US Environmental Protection Agency ("EPA") are
pleased to explain the emission control system warranty on your 2017 engine. New off-road large
spark-ignition (LSI) engines must be designed, built and equipped to meet nationwide stringent
anti-smog standards.
UCA must warrant the emission control system on your engine for the periods of time listed below,
provided there has been no abuse, neglect or improper maintenance of your engine.
Your emission control system may include parts such as the carburetor, regulator or fuel-injection
system, ignition system, engine computer unit (ECM), catalytic converter and air induction system.
Also included may be sensors, hoses, belts, connectors and other emission-related assemblies.
Where a warrantable condition exists, an Authorized UCA Dealer will repair your LSI engine at no
cost to you including diagnosis, parts and labor.
MANUFACTURER'S WARRANTY COVERAGE
The 2017 off-road large spark-ignition engines are warranted for the time periods as listed below.
If any emission-related part on your engine is defective, the part will be repaired or replaced by
an Authorized UCA Dealer.
OWNER'S WARRANTY RESPONSIBILITES
As the off-road LSI engine owner, you are responsible for the performance of the required
maintenance listed in your operator's manual. UCA recommends that you retain receipts covering
maintenance on your off-road engine, but UCA cannot deny warranty solely for the lack of receipts
or for your failure to ensure the performance of all scheduled maintenance.
As the off-road large spark-ignition engine owner, you should however be aware that UCA may
deny you warranty coverage if your off-road large spark-ignition engine or a part thereof has failed
due to abuse, neglect, improper maintenance or unapproved modifi cations.
Your engine is designed to operate on gasoline or LPG fuel. Use of any other fuel may result in
your engine no longer operating in compliance with the emissions requirements.
You are responsible for initiating the warranty process. The ARB and US EPA suggests that
you present your off-road large spark-ignition engine to an Authorized UCA Dealer as soon as
a problem exists. The warranty repairs should be completed by the Dealer as expeditiously as
possible.
UniCarriers Americas Corporation 240 N. Prospect Street, Marengo, IL 60152
R
OWNER'S WARRANTY RESPONSIBILITES (cont'd)
If you have any questions regarding your warranty rights and responsibilities, you should contact
the following:
UCA's Customer Quality Department at 1-815-568-0061
EMISSION CONTROL WARRANTY COVERAGES
The warranty coverage's stated below are in months and hours from the date of the fi rst use
by the original purchaser from an Authorized UCA Dealer, whichever occurs fi rst, UCA warrants
the following emission-related parts.
Emission Control Warranty
36 months or 2,500 hours (General Parts)
• Oxygen sensor
• PCV valve
• Water temperature sensor
• Gasoline injector
• LPG injector
• LPG pressure sensor
• LPG solenoid
• Mass air fl ow sensor
• Throttle chamber
• Ignition coil
• Crankshaft position sensor
• Camshaft position sensor
• Spark plugs
• Exhaust tube from manifold to
catalytic converter
• Gasoline fuel hose
• Gasoline fuel cap
• Absolute pressure sensor
EXCLUSIONS AND LIMITATIONS
The warranties contained herein shall not apply to or include any of the following:
1. Repair or replacement required as a result of: accident; misuse or neglect; lack of
reasonable and proper maintenance; repairs improperly performed or replacements
improperly installed; use of replacement parts or accessories not conforming to UCA's
specifi cations which adversely affect performance and/or durability; alterations or
modifi cations not recommended or approved in writing by UCA.
2. Normal replacement of service items
3. Normal maintenance services (such as engine tune-ups, fuel system cleaning, linkage
adjustments, and lubrication services)
207
Emission Control Warranty
36 months or 4,000 hours (Power Train Parts)
• Intake manifold
• Exhaust manifold
Long-Term Emission Control
Warranty
60 months or 3,500 hours (General Parts)
• ECM
• Catalytic converter
• Vaporizer
UCA 2017 K21-K25 WARSTAT (01/2017)