Perkins 1104E Series Troubleshooting Manual page 4

4
Table of Contents
CID 1684 FMI 03 Fuel Injection Pump, Fuelling
Fault .................................................................... 77
CID 1684 FMI 04 Fuel Injection Pump, Supply
Voltage Fault ....................................................... 77
CID 1684 FMI 05 Fuel Injection Pump, Invalid Pulse
Width ................................................................... 78
CID 1684 FMI 07 Fuel Injection Pump, Mechanical
Fault .................................................................... 78
CID 1684 FMI 08 Fuel Injection Pump, Crankshaft
Reference Fault .................................................. 79
CID 1684 FMI 09 Fuel Injection Pump, CAN
Fault .................................................................... 80
CID 1684 FMI 10 Fuel Injection Pump, Fuel Shutoff
Signal Error ......................................................... 80
CID 1684 FMI 11 Fuel Injection Pump, Internal
Sensor Fault ........................................................ 81
CID 1684 FMI 12 Fuel Injection Pump, Device
Failure ................................................................. 81
CID 1684 FMI 14 Fuel Injection Pump, No
Communications ................................................. 82
CID 1743 FMI 02 Engine Speed Mode Selection
Switch State, Invalid State .................................. 83
CID 1894 FMI 02 Set Speed Control Disengage
Switch State, Invalid State .................................. 83
CID 1895 FMI 02 Set Speed Control Speed Toggle
Switch, Invalid State ............................................ 83
Troubleshooting with an Event Code
Event Codes ........................................................ 85
E015 High Engine Coolant Temperature Derate .. 85
E016 High Engine Coolant Temperature
Shutdown ............................................................ 85
E017 High Engine Coolant Temperature
Warning ............................................................... 85
E025 High Intake Air Temperature Derate ............ 86
E027 High Intake Air Temperature Warning ......... 86
E040 Low Engine Oil Pressure Shutdown ............ 86
E054 High Fuel Temperature Derate .................... 87
E056 High Fuel Temperature Warning .................. 88
E100 Low Engine Oil Pressure Warning ............... 89
E190 Engine Overspeed Warning ........................ 90
E442 Engine Failed to Stop with a No-Fuel
Command ........................................................... 90
E883 Engine Failed To Stop When Fuel Solenoid
Disengaged ......................................................... 91
Diagnostic Functional Tests
5 Volt Engine Pressure Sensor Supply Circuit -
Test ..................................................................... 92
Air Inlet Heater Circuit - Test ................................. 99
Analog Throttle Position Sensor Circuit - Test .... 104
CAN Data Link Circuit - Test ................................ 113
Data Link Circuit - Test ......................................... 118
Digital Throttle Position Sensor Circuit - Test ..... 126
Electrical Connectors - Inspect ........................... 135
Electrical Power Supply Circuit - Test ................. 146
Engine Oil Level Switch Circuit - Test ................. 152
Engine Pressure Sensor Open or Short Circuit -
Test ................................................................... 157
Engine Speed/Timing Sensor Circuit - Test ........ 164
Engine Temperature Sensor Open or Short Circuit -
Test ................................................................... 171
Fuel Injection Pump Circuit - Test ....................... 178
Indicator Lamp Circuit - Test ............................... 195
Mode Selection Circuit - Test .............................. 198
Set Speed Circuit - Test ...................................... 204
Throttle Switch Circuit - Test ............................... 212
Index Section
Index ................................................................... 221
RENR2696-01