Perkins 1104E Series Troubleshooting Manual page 222

222
Index Section
CID 1743 FMI 02 Engine Speed Mode Selection
Switch State, Invalid State ................................... 83
CID 1894 FMI 02 Set Speed Control Disengage
Switch State, Invalid State ................................... 83
CID 1895 FMI 02 Set Speed Control Speed Toggle
Switch, Invalid State ............................................ 83
Coolant in Engine Oil............................................. 38
Probable Causes ............................................... 38
Recommended Actions...................................... 38
Coolant Temperature Is Too High .......................... 39
Probable Causes ............................................... 39
Recommended Actions...................................... 39
D
Data Link Circuit - Test ......................................... 118
Diagnostic Codes .................................................. 13
Diagnostic Functional Tests................................... 92
Digital Throttle Position Sensor Circuit - Test ...... 126
E
E015 High Engine Coolant Temperature Derate ... 85
E016 High Engine Coolant Temperature
Shutdown............................................................. 85
E017 High Engine Coolant Temperature Warning.. 85
E025 High Intake Air Temperature Derate............. 86
E027 High Intake Air Temperature Warning .......... 86
E040 Low Engine Oil Pressure Shutdown............. 86
E054 High Fuel Temperature Derate..................... 87
E056 High Fuel Temperature Warning .................. 88
E100 Low Engine Oil Pressure Warning ............... 89
E190 Engine Overspeed Warning ......................... 90
E442 Engine Failed to Stop with a No-Fuel
Command ............................................................ 90
E883 Engine Failed To Stop When Fuel Solenoid
Disengaged.......................................................... 91
ECM Will Not Accept Factory Passwords.............. 40
Probable Causes ............................................... 40
Recommended Actions...................................... 40
ECM Will Not Communicate with Other Systems or
Display Modules .................................................. 40
Probable Causes ............................................... 40
Recommended Actions...................................... 40
Electrical Connectors - Inspect............................ 135
Electrical Power Supply Circuit - Test.................. 146
Electronic Service Tool Will Not Communicate with
ECM..................................................................... 40
Probable Causes ............................................... 40
Recommended Actions...................................... 41
Electronic Service Tools ........................................ 12
Electronic Service Tool....................................... 12
Electronic Troubleshooting ...................................... 5
Engine Cranks but Will Not Start ........................... 41
Probable Causes ............................................... 41
Recommended Actions...................................... 41
Engine Has Early Wear ......................................... 43
Probable Causes ............................................... 43
Recommended Actions...................................... 43
Engine Misfires, Runs Rough or Is Unstable......... 43
Probable Causes ............................................... 44
Recommended Actions...................................... 44
Engine Oil in Cooling System ................................ 46
Probable Causes ............................................... 46
Recommended Actions...................................... 46
Engine Oil Level Switch Circuit - Test.................. 152
Engine Pressure Sensor Open or Short Circuit -
Test .................................................................... 157
Engine Speed Does Not Change .......................... 46
Probable Causes ............................................... 46
Recommended Repairs ..................................... 46
Engine Speed/Timing Sensor Circuit - Test......... 164
Engine Stalls at Low RPM ..................................... 47
Probable Causes ............................................... 47
Recommended Actions...................................... 47
Engine Temperature Sensor Open or Short Circuit -
Test .................................................................... 171
Engine Vibration .................................................... 48
Probable Causes ............................................... 48
Recommended Actions...................................... 48
Engine Will Not Crank ........................................... 49
Probable Causes ............................................... 49
Recommended Repairs ..................................... 49
Engine Wiring Information ..................................... 26
Harness Wire Identification ................................ 31
Machine Interface Connector............................. 26
Event Codes .......................................................... 85
Programmable Engine Parameters.................... 85
Excessive Black Smoke ........................................ 50
Probable Causes ............................................... 50
Recommended Actions...................................... 50
Excessive Engine Oil Consumption....................... 51
Probable Causes ............................................... 51
Recommended Actions...................................... 51
Excessive Valve Lash............................................ 52
Probable Causes ............................................... 52
Recommended Actions...................................... 52
Excessive White Smoke ........................................ 53
Probable Causes ............................................... 53
Recommended Actions...................................... 53
F
Factory Passwords ................................................ 32
Customer Passwords......................................... 32
Factory Passwords ............................................ 32
Passwords ......................................................... 32
Flash Programming ............................................... 32
Flash Programming a Personality Module ......... 33
Fuel Injection Pump Circuit - Test........................ 178
G
Glossary .................................................................. 9
RENR2696-01