10 Service Schedule; Additional Information; Required Work - KTM Freeride 250 F 2018 Owner's Manual

10 SERVICE SCHEDULE

10.1
Any further work that results from the required work or from the recommended work must be ordered separately
and can be invoiced separately.
Different service intervals may apply in your country, depending on the local operating conditions.
Individual service intervals and scopes may change in the course of technical developments. The most up-to-date
service schedule can always be found on KTM Dealer.net. Your authorized KTM dealer will be happy to advise
you.
10.2
Read out the fault memory using the KTM diagnostics tool.
Check that the electrical system is functioning properly.
Check and charge the battery.
Change the engine oil and oil filter, clean the oil screen.
Check the front brake linings. (
Check the rear brake linings. (
Check the brake discs. (
Check the brake lines for damage and leakage.
Change the foot brake cylinder seals.
Check the rear brake fluid level. (
Check the free travel of the foot brake lever. (
Check the frame.
Check the swingarm.
Check the swingarm bearing for play.
Check the heim joint for play.
Check the tire condition. (
Check the tire air pressure. (
Check the wheel bearing for play.
Check the wheel hubs.
Check the rim run-out.
Check the spoke tension. (
Check the chain, rear sprocket, engine sprocket and chain guide. (
Check the chain tension. (
Grease all moving parts (e.g. side stand, hand lever, chain, etc.) and check for smooth opera-
tion.
Check the fluid level of the hydraulic clutch. (
Check the brake fluid level of the front brake. (
Check the free travel of the hand brake lever. (
Check the steering head bearing play. (
Check the valve clearance.
Check the clutch.
Change the cover seal and shaft seal rings of the water pump.
Change the fuel screen.
42

Additional information

Required work

p. 87)
p. 92)
p. 84)
p. 90)
( p. 79)
( p. 79)
p. 98)
p. 99)
p. 100)
p. 75)
( p. 122)
( p. 123)
p. 89)
p. 76)
p. 80)
p. 85)
p. 84)
p. 60)
Every 80 operating hours
Every 40 operating hours
Every 20 operating hours
Once after 1 operating hour
○ ●
○ ●
●
○ ●
●
●
●
●
●
●
●
●
●
○ ●
○ ●
●
●
○ ●
○ ●
●
○ ●
○ ●
●
●
●
○ ●
○
○ ●
● ●
● ●
● ●
● ●
● ●
● ●
● ●
● ●
● ●
● ●
● ●
● ●
● ●
●
● ●
● ●
● ●
● ●
● ●
● ●
● ●
● ●
● ●
● ●
● ●
● ●
● ●
● ●
●
●
●
● ●